Volvo All Engines (2010 Emissions) Fault Code: SPN 412 FMI 4 PID: Engine Exhaust Gas Recirculation Temperature

Category All Engines (2010 Emissions) Tags 2010, 4, 412, All, CodeSPN, Emissions, Engine, Engines, Exhaust, Fault, FMI, Gas, PID, Recirculation, Temperature, Volvo

This function is used to check if the Exhaust Gas Recirculation (EGR) temperature sensor is working and check the status on the EGR cooler. If the sensor should show a value above limit due to extreme driving or malfunction in the cooler, the Engine Control Module (ECM) will derate the engine to avoid damage.

Conditions for diagnostic trouble code (DTC):
1) The voltage at pin A14.EB:48 is less than 0.024?V

Observable symptoms
1) Engine de-rated

Probable cause
1) Connector
2) Temperature sensor, EGR
3) Open circuit, Ground wire
4) Short circuit to higher voltage, Signal wire
5) Wiring harness
6) Engine control module (ECM)

CLAAS
CLAAS MetaDiag 2007 Update 2016
Rated 0 out of 5
$200.00 Add to cart
ISUZU
Isuzu US-IDSS 2024 Diagnostic
Rated 0 out of 5
$220.00 Add to cart
ISUZU
Isuzu E-IDSS 2023 Diagnostic Software
Rated 0 out of 5
$150.00 Add to cart
ISUZU
ISUZU G-IDSS Domestic Japan 2024 Diagnostic Software
Rated 0 out of 5
$220.00 Add to cart

VOLVO PROSIS 2023 ( 11.2022 )
Trucks software $96.00
Rated 0 out of 5
CLAAS CDS 7.5
CLAAS $200.00
Rated 0 out of 5
Volvo PROSIS Offline 2019 Parts Catalog Installation Service
Trucks software $45.00
Rated 0 out of 5
Navistar Diamond Logic Builder 2023 (DLB)
Navistar $94.00
Rated 0 out of 5
Allison DOC Premium 2023
Allison $96.00
Rated 0 out of 5
volvo Devtool Studio V2 / V3 / V4 Developer tool plus 2.6 / 2.7
Trucks software $35.00
Rated 0 out of 5
CUMMINnSsg INSITEr 8.7.0.86 PRO + ZAP-IT
cummisznn $70.00
Rated 0 out of 5
Isuzu E-IDSS 2023 Diagnostic Software
ISUZU $150.00
Rated 0 out of 5
Nexiq eTechnician 2.0.7447 2020
NEXIQ $55.00
Rated 0 out of 5
Volvo Penta EPC 6 Offline VMware [12.2021] VMware
Trucks software $64.00
Rated 0 out of 5
Wabco ToolBox plus 13.7 + ECAS CAN2 v3.00 Diagnostics Software
Trucks software $84.00
Rated 0 out of 5
JPRO 2023 v3 diagnostic software latest version
JPRO $100.00
Rated 0 out of 5
Navistar Engine Diagnostics (NEDS) 2023
Navistar $96.00
Rated 0 out of 5
JOHN DEERE PARTS ADVISOR & HITACHI 2.24.2 [2023.07] EPC
Hitachi $125.00
Rated 0 out of 5
Bell Cancomm 5.07.0 diagnostic software
BELL $125.00
Rated 0 out of 5

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 692 PID: 351 SPN: 1172 FMI: 4 Turbocharger 1 Compressor Intake Temperature Circuit- Voltage Below Normal or Shorted to Low Source
Cumminz
Rated 0 out of 5
Cummins ISB6.7 CM2150 (2007-09) Fault Code: 1879 PID: SID 324 SPN: 3251 FMI: 3 Aftertreatment Particulate Filter Differential Pressure Sensor Circuit – Voltage Above Normal or Shorted to High Source. High signal voltage detected at the aftertreatment differential pressure sensor circuit.
Cumminz
Rated 0 out of 5
CAT 3126B Fault Code: 100-11 PID: Flash Code 46 SPN: 100 FMI: 18 Very Low Oil Pressure
3126B
Rated 0 out of 5
Volvo All Engines (2017 Emissions) Fault Code: P24FC00 PID: EMS Particulate Matter Sensor Heater Control Circuit Driver Current/Temperature Too High
All Engines (2017 Emissions)
Rated 0 out of 5
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 107 FMI 4 (CPC) Air Filter Sensor Failed Low
DD16 GHG14 (2014-16)
Rated 0 out of 5
Cummins ISB4.5 CM2150 Fault Code: 4284 PID: SPN: 5793 FMI: 9 Desired Engine Fueling State – Abnormal Update Rate.
Cumminz
Rated 0 out of 5
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 4353 FMI 4 (ACM) Diffuser Heater Circuit Failed Low
DD16 GHG14 (2014-16)
Rated 0 out of 5
Allison 3000 & 4000 Gen 4 Fault Code: P2761 TCC PCS Control Circuit Open
3000 & 4000 Gen 4
Rated 0 out of 5
Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 115 PID: PID 190 SPN: 612 FMI: 2 Engine Magnetic Speed/Position Lost Both of Two Signals- Data Erratic, Intermittent, or Incorrect
Cumminz
Rated 0 out of 5
PACCAR PX-9 CM2350 (2013-17) Fault Code:3422 PID: SPN:4344 FMI:3 Aftertreatment Diesel Exhaust Fluid Line Heater 3 Circuit – Voltage Above Normal or Shorted to High Source
DTC TRUCKS
Rated 0 out of 5
Detroit DD13 GHG14 (2014-16) Fault Code: SPN 110 FMI 2 (MCM) Coolant Outlet Temperature Not Plausible
DD13 GHG14 (2014-16)
Rated 0 out of 5
Volvo All Engines (2017 Emissions) Fault Code: P224311 PID: EMS O2 Sensor Reference Voltage Bank 1 Sensor 1
All Engines (2017 Emissions)
Rated 0 out of 5
PACCAR PX-9 CM2350 (2013-17) Fault Code:143 PID:100 SPN:100 FMI:1 Engine Oil Rifle Pressure – Data Valid But Below Normal Operational Range – Moderately Severe Level
DTC TRUCKS
Rated 0 out of 5
Detroit DD15 EPA07 (2007-09) Fault Code: SPN 3695 FMI 9 (CPC) Diesel Particulate Filter Regeneration Inhibit Switch or Force Switch Message Stopped Arriving
DD15 EPA07 (2007-09)
Rated 0 out of 5
Detroit DD13 EPA10 (2010-13) Fault Code: SPN 3364 FMI 2 (ACM) Improper Diesel Exhaust Fluid Quality
DD13 EPA10 (2010-13)
Rated 0 out of 5
Cummins ISX12 CM2250 (2010-12) Fault Code: 418 PID: 97 SPN: 97 FMI: 15 Water-In-Fuel Indicator- Data Valid But Above Normal Operating Range- Least Severe Level
Cumminz
Rated 0 out of 5
Cummins ISC CM2150 (2007-09) Fault Code: 2555 PID: SID 070 SPN: 729 FMI: 3 Intake Air Heater 1 Circuit – Voltage Above Normal or Shorted to High Source. High voltage detected at the intake air heater signal circuit.
Cumminz
Rated 0 out of 5
Detroit DD15 GHG14 (2014-16) Fault Code: SPN 677 FMI 2 (MCM) Starter Switch Inconsistent
DD15 GHG14 (2014-16)
Rated 0 out of 5

Volvo All Engines (2010 Emissions) Fault Code: SPN 412 FMI 4 PID: Engine Exhaust Gas Recirculation Temperature

CLAAS MetaDiag 2007 Update 2016

Isuzu US-IDSS 2024 Diagnostic

Isuzu E-IDSS 2023 Diagnostic Software

ISUZU G-IDSS Domestic Japan 2024 Diagnostic Software

VOLVO PROSIS 2023 ( 11.2022 )

CLAAS CDS 7.5

Volvo PROSIS Offline 2019 Parts Catalog Installation Service

Navistar Diamond Logic Builder 2023 (DLB)

Allison DOC Premium 2023

volvo Devtool Studio V2 / V3 / V4 Developer tool plus 2.6 / 2.7

CUMMINnSsg INSITEr 8.7.0.86 PRO + ZAP-IT

Isuzu E-IDSS 2023 Diagnostic Software

Nexiq eTechnician 2.0.7447 2020

Volvo Penta EPC 6 Offline VMware [12.2021] VMware

Wabco ToolBox plus 13.7 + ECAS CAN2 v3.00 Diagnostics Software

JPRO 2023 v3 diagnostic software latest version

Navistar Engine Diagnostics (NEDS) 2023

JOHN DEERE PARTS ADVISOR & HITACHI 2.24.2 [2023.07] EPC

Bell Cancomm 5.07.0 diagnostic software

Related products

Cummins ISB4.5 CM2150 Fault Code: 3697 PID: SID 254 SPN: 630 FMI: 12 Engine Control Module Calibration Memory – Bad Intelligent Device or Component.

Cummins ISB4.5 CM2150 Fault Code: 3383 PID: 411 SPN: 3058 FMI: 0 Engine Exhaust Gas Recirculation System – Data Valid But Above Normal Operating Range – Moderately Severe Level.

Cummins ISB4.5 CM2150 Fault Code: 3735 PID: SPN: 2884 FMI: 9 Engine Auxiliary Governor Switch – Abnormal Update Rate.

Cummins ISB4.5 CM2150 Fault Code: 3737 PID: SID 115 SPN: 1675 FMI: 11 Engine Starter Mode Overcrank Protection – Condition Exists.

Cummins ISB4.5 CM2150 Fault Code: 111 PID: 629 FMI:12 Engine Control Module Critical Internal Failure – Bad Intelligent Device or Component

Cummins ISB4.5 CM2150 Fault Code: 2321 PID: 190 SPN: 190 FMI: 2 Engine Crankshaft Speed/Position – Data Erratic, Intermittent, or Incorrect.

Cummins ISB4.5 CM2150 Fault Code: 2963 PID: 110 SPN: 110 FMI: 0 Engine Coolant Temperature – Data Valid But Above Normal Operating Range – Least Severe Level.

Cummins ISB4.5 CM2150 Fault Code: 2363 PID: SID 29 SPN: 1073 FMI: 4 Engine Brake Actuator Driver Output 2 Circuit – Voltage Below Normal or Shorted to Low Source.

Cummins ISB4.5 CM2150 Fault Code: 3616 PID: SPN: 2633 FMI: 7 Engine VGT Nozzle Position – Mechanical System Not Responding or Out of Adjustment.

Cummins ISB4.5 CM2150 Fault Code: 2182 PID: 478 SPN: 1072 FMI: 3 Engine Brake Actuator Driver 1 Circuit – Voltage Above Normal or Shorted to High Source.

Cummins ISB4.5 CM2150 Fault Code: 2369 PID: SPN: 1074 FMI: 4 Engine (Exhaust) Brake Driver Circuit – Voltage Below Normal or Shorted to Low Source.

Cummins ISB4.5 CM2150 Fault Code: 2183 PID: 477 SPN: 1072 FMI: 4 Engine Brake Actuator Driver 1 Circuit – Voltage Below Normal or Shorted to Low Source.

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 692 PID: 351 SPN: 1172 FMI: 4 Turbocharger 1 Compressor Intake Temperature Circuit- Voltage Below Normal or Shorted to Low Source

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 1879 PID: SID 324 SPN: 3251 FMI: 3 Aftertreatment Particulate Filter Differential Pressure Sensor Circuit – Voltage Above Normal or Shorted to High Source. High signal voltage detected at the aftertreatment differential pressure sensor circuit.

CAT 3126B Fault Code: 100-11 PID: Flash Code 46 SPN: 100 FMI: 18 Very Low Oil Pressure

Volvo All Engines (2017 Emissions) Fault Code: P24FC00 PID: EMS Particulate Matter Sensor Heater Control Circuit Driver Current/Temperature Too High

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 107 FMI 4 (CPC) Air Filter Sensor Failed Low

Cummins ISB4.5 CM2150 Fault Code: 4284 PID: SPN: 5793 FMI: 9 Desired Engine Fueling State – Abnormal Update Rate.

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 4353 FMI 4 (ACM) Diffuser Heater Circuit Failed Low

Allison 3000 & 4000 Gen 4 Fault Code: P2761 TCC PCS Control Circuit Open

Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 115 PID: PID 190 SPN: 612 FMI: 2 Engine Magnetic Speed/Position Lost Both of Two Signals- Data Erratic, Intermittent, or Incorrect

PACCAR PX-9 CM2350 (2013-17) Fault Code:3422 PID: SPN:4344 FMI:3 Aftertreatment Diesel Exhaust Fluid Line Heater 3 Circuit – Voltage Above Normal or Shorted to High Source

Detroit DD13 GHG14 (2014-16) Fault Code: SPN 110 FMI 2 (MCM) Coolant Outlet Temperature Not Plausible

Volvo All Engines (2017 Emissions) Fault Code: P224311 PID: EMS O2 Sensor Reference Voltage Bank 1 Sensor 1

PACCAR PX-9 CM2350 (2013-17) Fault Code:143 PID:100 SPN:100 FMI:1 Engine Oil Rifle Pressure – Data Valid But Below Normal Operational Range – Moderately Severe Level

Detroit DD15 EPA07 (2007-09) Fault Code: SPN 3695 FMI 9 (CPC) Diesel Particulate Filter Regeneration Inhibit Switch or Force Switch Message Stopped Arriving

Detroit DD13 EPA10 (2010-13) Fault Code: SPN 3364 FMI 2 (ACM) Improper Diesel Exhaust Fluid Quality

Cummins ISX12 CM2250 (2010-12) Fault Code: 418 PID: 97 SPN: 97 FMI: 15 Water-In-Fuel Indicator- Data Valid But Above Normal Operating Range- Least Severe Level

Cummins ISC CM2150 (2007-09) Fault Code: 2555 PID: SID 070 SPN: 729 FMI: 3 Intake Air Heater 1 Circuit – Voltage Above Normal or Shorted to High Source. High voltage detected at the intake air heater signal circuit.

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 677 FMI 2 (MCM) Starter Switch Inconsistent

Store

About

Features

Follow Us