Volvo All Engines (2010 Emissions) Fault Code: SPN 631 FMI 12 PID: PSID 7 Calibration memory

Category All Engines (2010 Emissions) Tags 12, 2010, 631, 7, All, Calibration, CodeSPN, Emissions, Engines, Fault, FMI, Memory, PIDPSID, Volvo

Conditions for diagnostic trouble code (DTC):
1) Internal fault in electronic control unit (ECU)

Observable symptoms
1) No aftertreatment diesel exhaust fluid (DEF) dosage

Probable cause
1) Dosage electronic control unit (ECU), pump unit

CAT
CAT ET 2026 Diagnostic Software
$110.00 Add to cart
Detroit
DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026
$120.00 Add to cart
Detroit
DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025
$110.00 Add to cart
John Deere
John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible
$420.00 Add to cart

2021 VOLVO PREMIUM TECH TOOL PTT V2.8.21 VCADS+DEVELOPER TOOL+APCI 2021/09 ( 1 PC )
Trucks software $85.00
Allison DOC 2021 V2 (1PC)
Allison $67.00
Isuzu IDSS 2021 Diagnostic Software
ISUZU $100.00

PACCAR MX (2004 Emissions) Fault Code: P0110 Inlet Air Temperature in Inlet Manifold – Data Erratic, Intermittent or Incorrect, at Ignition On
MX (2004 Emissions)
Allison WTEC II Fault Code: 57 PID: SPN: 88 FMI: Range verification C3PS test, N1
Allison
Detroit DD13 EPA07 (2007-09) Fault Code: SPN 1072 FMI 5 (MCM) Jake Brake Stage 1 Circuit Failed Open
DD13 EPA07 (2007-09)
Cummins ISX CM870 (2003-06) Fault Code: 429 PID: P097 SPN: 97 FMI: 4/4 Water-in-Fuel Indicator Sensor Circuit – Voltage Below Normal or Shorted to Low Source. Low voltage detected at the water-in-fuel circuit.
Cumminz
Detroit DD15 EPA10 (2010-13) Fault Code: SPN 3659 FMI 6 (MCM) Injector Cylinder #1 Amplifier Control Valve – Valve Shorted Circuit
DD15 EPA10 (2010-13)
PACCAR MX (2004 Emissions) Fault Code: P1057 Exhaust Gas Pressure Before Turbine – Data Valid but Too Low
MX (2004 Emissions)
Volvo All Engines (2010 Emissions) Fault Code: SPN 3480 FMI 3 PID: PPID 437 Aftertreatment DPF Fuel Pressure
All Engines (2010 Emissions)
Allison 1000 & 2000 Gen 5 Fault Code:P0878 Transmission Fluid Pressure Switch 4 (PS4) Circuit – High
1000 & 2000 Gen 5
Volvo All Engines (2013 Emissions) Fault Code: P102A00 PID: EMS Cold Start Fuel injection Quanitity Lower Than Expected
All Engines (2013 Emissions)
PACCAR PX-9 CM2350 (2013-17) Fault Code:3141 PID: SPN:3667 FMI:4 Engine Air Shutoff Circuit – Voltage Below Normal or Shorted to Low Source
DTC TRUCKS
Cummins ISB4.5 CM2150 Fault Code: 196 PID: 2558 SPN: 11 FMI: 4 Coolant Level Sensor 1 Circuit – Voltage Below Normal or Shorted to Low Source.
Cumminz
Detroit DD16 EPA07 (2007-09) Fault Code: SPN 2791 FMI 3 (MCM) Circuit Failed High
DD16 EPA07 (2007-09)
Cummins ISB4.5 CM2150 Fault Code: 331 PID: SID 6 SPN: 652 FMI: 5 Injector Solenoid Driver Cylinder 2 Circuit – Current Below Normal or Open Circuit.
Cumminz
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 3364 FMI 18 (ACM) Improper Diesel Exhaust Fluid Quality Warning
DD16 GHG14 (2014-16)
Detroit DD13 GHG14 (2014-16) Fault Code: SPN 3609 FMI 3 (ACM) Diesel Oxidation Catalyst Inlet Pressure Sensor Circuit Failed High
DD13 GHG14 (2014-16)
PACCAR PX-8 CM2150 (2007-09) Fault Code: 285 PID: SID 231 SPN: 639 FMI: 9 SAE J1939 Multiplexing PGN Timeout Error – Abnormal Update Rate. The ECM expected information from a multiplexed device but did not receive it soon enough or did not receive it at all.
DTC TRUCKS
PACCAR PX-6 CM2150 (2007-09) Fault Code: 296 PID: 223 SPN: 1388 FMI: 14 Auxiliary Pressure Sensor Input 1 – Special Instructions
DTC TRUCKS
Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 8194 PID: SPN: 2852 FMI: 12/12 Communications Service Subscriber Identification Module – Bad Intelligent Device or Component
Cumminz

Volvo All Engines (2010 Emissions) Fault Code: SPN 631 FMI 12 PID: PSID 7 Calibration memory

CAT ET 2026 Diagnostic Software

DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026

DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025

John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible

2021 VOLVO PREMIUM TECH TOOL PTT V2.8.21 VCADS+DEVELOPER TOOL+APCI 2021/09 ( 1 PC )

Allison DOC 2021 V2 (1PC)

Isuzu IDSS 2021 Diagnostic Software

PACCAR MX (2004 Emissions) Fault Code: P0110 Inlet Air Temperature in Inlet Manifold – Data Erratic, Intermittent or Incorrect, at Ignition On

Allison WTEC II Fault Code: 57 PID: SPN: 88 FMI: Range verification C3PS test, N1

Detroit DD13 EPA07 (2007-09) Fault Code: SPN 1072 FMI 5 (MCM) Jake Brake Stage 1 Circuit Failed Open

Cummins ISX CM870 (2003-06) Fault Code: 429 PID: P097 SPN: 97 FMI: 4/4 Water-in-Fuel Indicator Sensor Circuit – Voltage Below Normal or Shorted to Low Source. Low voltage detected at the water-in-fuel circuit.

Detroit DD15 EPA10 (2010-13) Fault Code: SPN 3659 FMI 6 (MCM) Injector Cylinder #1 Amplifier Control Valve – Valve Shorted Circuit

PACCAR MX (2004 Emissions) Fault Code: P1057 Exhaust Gas Pressure Before Turbine – Data Valid but Too Low

Volvo All Engines (2010 Emissions) Fault Code: SPN 3480 FMI 3 PID: PPID 437 Aftertreatment DPF Fuel Pressure

Allison 1000 & 2000 Gen 5 Fault Code:P0878 Transmission Fluid Pressure Switch 4 (PS4) Circuit – High

Volvo All Engines (2013 Emissions) Fault Code: P102A00 PID: EMS Cold Start Fuel injection Quanitity Lower Than Expected

PACCAR PX-9 CM2350 (2013-17) Fault Code:3141 PID: SPN:3667 FMI:4 Engine Air Shutoff Circuit – Voltage Below Normal or Shorted to Low Source

Cummins ISB4.5 CM2150 Fault Code: 196 PID: 2558 SPN: 11 FMI: 4 Coolant Level Sensor 1 Circuit – Voltage Below Normal or Shorted to Low Source.

Detroit DD16 EPA07 (2007-09) Fault Code: SPN 2791 FMI 3 (MCM) Circuit Failed High

Cummins ISB4.5 CM2150 Fault Code: 331 PID: SID 6 SPN: 652 FMI: 5 Injector Solenoid Driver Cylinder 2 Circuit – Current Below Normal or Open Circuit.

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 3364 FMI 18 (ACM) Improper Diesel Exhaust Fluid Quality Warning

Detroit DD13 GHG14 (2014-16) Fault Code: SPN 3609 FMI 3 (ACM) Diesel Oxidation Catalyst Inlet Pressure Sensor Circuit Failed High

PACCAR PX-8 CM2150 (2007-09) Fault Code: 285 PID: SID 231 SPN: 639 FMI: 9 SAE J1939 Multiplexing PGN Timeout Error – Abnormal Update Rate. The ECM expected information from a multiplexed device but did not receive it soon enough or did not receive it at all.

PACCAR PX-6 CM2150 (2007-09) Fault Code: 296 PID: 223 SPN: 1388 FMI: 14 Auxiliary Pressure Sensor Input 1 – Special Instructions

Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 8194 PID: SPN: 2852 FMI: 12/12 Communications Service Subscriber Identification Module – Bad Intelligent Device or Component

Store

About

Features

Follow Us

Volvo All Engines (2010 Emissions) Fault Code: SPN 631 FMI 12 PID: PSID 7 Calibration memory

CAT ET 2026 Diagnostic Software

DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026

DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025

John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible

2021 VOLVO PREMIUM TECH TOOL PTT V2.8.21 VCADS+DEVELOPER TOOL+APCI 2021/09 ( 1 PC )

Allison DOC 2021 V2 (1PC)

Isuzu IDSS 2021 Diagnostic Software

Related products

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 1896 PID: SID 146 SPN: 2791 FMI: 13 EGR Valve Controller – Out of Calibration. The EGR valve has failed the automatic calibration procedure at initial key-on.

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 1896 PID: SID 146 SPN: 2791 FMI: 13 EGR Valve Controller- Out of Calibration

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 3718 PID: SPN: 3216 FMI: 13 Aftertreatment Intake Nox- Out of Calibration

Cummins ISB4.5 CM2150 Fault Code: 346 PID: 253 SPN: 630 FMI: 12 Engine Control Module Calibration Memory Software – Bad Intelligent Device or Component.

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 2449 PID: SID 027 SPN: 641 FMI: 13 VGT Actuator Controller – Out of Calibration. The VGT has failed the automatic calibration procedure at initial key-ON.

ddct Detroit diesel calibration tool (DDCT) v4.5 English Include Calibrations & Metafiles

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 2449 PID: SID 27 SPN: 641 FMI: 13 VGT Actuator Controller- Out of Calibration

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 2635 PID: SID 027 SPN: 641 FMI: 11 VGT Actuator Driver Circuit – Condition Exists. A calibration mismatch between the VGT actuator and the ECM has been detected.

PACCAR PX-6 CM2150 (2007-09) Fault Code: 1896 PID: SID 146 SPN: 2791 FMI: 13 EGR Valve Controller – Out of Calibration. The EGR valve has failed the automatic calibration procedure at initial key-on.

PACCAR PX-8 CM2150 (2007-09) Fault Code: 2449 PID: SID 027 SPN: 641 FMI: 13 VGT Actuator Controller – Out of Calibration. The VGT has failed the automatic calibration procedure at initial key-ON.

PACCAR PX-8 CM2150 (2007-09) Fault Code: 1896 PID: SID 146 SPN: 2791 FMI: 13 EGR Valve Controller – Out of Calibration. The EGR valve has failed the automatic calibration procedure at initial key-on.

PACCAR MX (2004 Emissions) Fault Code: P0110 Inlet Air Temperature in Inlet Manifold – Data Erratic, Intermittent or Incorrect, at Ignition On

Allison WTEC II Fault Code: 57 PID: SPN: 88 FMI: Range verification C3PS test, N1

Detroit DD13 EPA07 (2007-09) Fault Code: SPN 1072 FMI 5 (MCM) Jake Brake Stage 1 Circuit Failed Open

Cummins ISX CM870 (2003-06) Fault Code: 429 PID: P097 SPN: 97 FMI: 4/4 Water-in-Fuel Indicator Sensor Circuit – Voltage Below Normal or Shorted to Low Source. Low voltage detected at the water-in-fuel circuit.

Detroit DD15 EPA10 (2010-13) Fault Code: SPN 3659 FMI 6 (MCM) Injector Cylinder #1 Amplifier Control Valve – Valve Shorted Circuit

PACCAR MX (2004 Emissions) Fault Code: P1057 Exhaust Gas Pressure Before Turbine – Data Valid but Too Low

Volvo All Engines (2010 Emissions) Fault Code: SPN 3480 FMI 3 PID: PPID 437 Aftertreatment DPF Fuel Pressure

Allison 1000 & 2000 Gen 5 Fault Code:P0878 Transmission Fluid Pressure Switch 4 (PS4) Circuit – High

Volvo All Engines (2013 Emissions) Fault Code: P102A00 PID: EMS Cold Start Fuel injection Quanitity Lower Than Expected

PACCAR PX-9 CM2350 (2013-17) Fault Code:3141 PID: SPN:3667 FMI:4 Engine Air Shutoff Circuit – Voltage Below Normal or Shorted to Low Source

Cummins ISB4.5 CM2150 Fault Code: 196 PID: 2558 SPN: 11 FMI: 4 Coolant Level Sensor 1 Circuit – Voltage Below Normal or Shorted to Low Source.

Detroit DD16 EPA07 (2007-09) Fault Code: SPN 2791 FMI 3 (MCM) Circuit Failed High

Cummins ISB4.5 CM2150 Fault Code: 331 PID: SID 6 SPN: 652 FMI: 5 Injector Solenoid Driver Cylinder 2 Circuit – Current Below Normal or Open Circuit.

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 3364 FMI 18 (ACM) Improper Diesel Exhaust Fluid Quality Warning

Detroit DD13 GHG14 (2014-16) Fault Code: SPN 3609 FMI 3 (ACM) Diesel Oxidation Catalyst Inlet Pressure Sensor Circuit Failed High

PACCAR PX-8 CM2150 (2007-09) Fault Code: 285 PID: SID 231 SPN: 639 FMI: 9 SAE J1939 Multiplexing PGN Timeout Error – Abnormal Update Rate. The ECM expected information from a multiplexed device but did not receive it soon enough or did not receive it at all.

PACCAR PX-6 CM2150 (2007-09) Fault Code: 296 PID: 223 SPN: 1388 FMI: 14 Auxiliary Pressure Sensor Input 1 – Special Instructions

Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 8194 PID: SPN: 2852 FMI: 12/12 Communications Service Subscriber Identification Module – Bad Intelligent Device or Component

Store

About

Features

Follow Us