Volvo All Engines (2010 Emissions) Fault Code: SPN 631 FMI 2 PID: PSID 124 Calibration memory

Category All Engines (2010 Emissions) Tags 124, 2, 2010, 631, All, Calibration, CodeSPN, Emissions, Engines, Fault, FMI, Memory, PIDPSID, Volvo

Conditions for diagnostic trouble code (DTC):
1) Software error
2) Checksum error, main software

Observable symptoms
1) Engine cannot be started

Probable cause
1) ACM EEPROM
2) Programmed with erroneous software
3) Programming sequence interrupted

CAT
CAT ET 2026 Diagnostic Software
$110.00 Add to cart
Detroit
DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026
$120.00 Add to cart
Detroit
DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025
$110.00 Add to cart
John Deere
John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible
$420.00 Add to cart

Volvo PROSIS Offline 2019 Parts Catalog Installation Service
Trucks software $45.00
Navistar Engine Diagnostics (NEDS) 2023
Navistar $96.00
Freightliner ServiceLink 4.9.6
Freightliner $30.00

Cummins ISB CM850 (2003-06) Fault Code: 595 (ISB) PID: 103 SPN: 103 FMI: 0 Turbocharger Number 1 speed high – warning level. High turbocharger speed has been detected.
Cumminz
Detroit DD15 EPA10 (2010-13) Fault Code: SPN 2631 FMI 3 (MCM, ACM) Intake Manifold Pressure Sensor Circuit Failed High
DD15 EPA10 (2010-13)
Detroit DD15 GHG14 (2014-16) Fault Code: SPN 653 FMI 4 (MCM) Injector Cylinder #3 Needle Control Valve Abnormal Operation (MIN)
DD15 GHG14 (2014-16)
PACCAR PX-9 CM2350 (2013-17) Fault Code:241 PID:84 SPN:84 FMI:2 Wheel-Based Vehicle Speed – Data Erratic, Intermittent, or Incorrect
DTC TRUCKS
Detroit DD15 EPA10 (2010-13) Fault Code: SPN 157 FMI 16 (MCM) Fuel Rail Pressure Too Low
DD15 EPA10 (2010-13)
Detroit DD15 EPA07 (2007-09) Fault Code: SPN 625 FMI 9 (MCM) No Data Received from Engine CAN Link
DD15 EPA07 (2007-09)
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 651 FMI 7 (MCM) Injector Cylinder #1 Needle Control Valve Stuck Open
DD16 GHG14 (2014-16)
Volvo All Engines (2013 Emissions) Fault Code: P02D100 PID: EMS Cylinder 3 fuel Injector Offset Learning At Max Limit
All Engines (2013 Emissions)
Cummins ISM CM870 (2003-06) Fault Code: 2376 PID: P412 SPN: 412 FMI: 4/4 Recirculated Exhaust Gas Temperature Sensor Circuit – Voltage Below Normal or Shorted to Low Source. Low signal voltage detected at EGR temperature circuit.
Cumminz
Cummins ISB6.7 CM2350 (2013-17) Fault Code: 3541 PID: SPN: 51 FMI: 4 Engine Intake Throttle ACtuator Position Sensor Circuit- Voltage Below Normal or Shorted to Low Source
Cumminz
Cummins ISX12 CM2250 (2010-12) Fault Code: 1879 PID: SID 324 SPN: 3251 FMI: 3 Aftertreatment Diesel Particulate Filter Differential Pressure Sensor Circuit- Voltage above Normal or Shorted to High Source
Cumminz
Detroit DD15 GHG14 (2014-16) Fault Code: SPN 520267 FMI 15 (MCM) Motor Control Module Engine Hours Data Erratic, Intermittent or Incorrect
DD15 GHG14 (2014-16)
Cummins ISB6.7 CM2350 (2013-17) Fault Code: 5792 PID: SPN: 7321 FMI: 4 Aftertreatment 1 Particulate Sensor Heater High Side Driver Circuit – Voltage Below Normal or Shorted to Low Source. An internal circuit error has been detected by the aftertreatment particulate matter sensor.
Cumminz
Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 123 PID: PID 102 SPN: 102 FMI: 4 Intake Manifold 1 Pressure Sensor Circuit- Voltage Below Normal or Shorted to Low Source
Cumminz
Cummins X15 CM2450 X124B (2018 & Newer) Fault Code: 7222 PID: SPN: 1112 FMI: 3/3 Engine Brake Actuator Driver 3 Circuit – Voltage Above Normal or Shorted to High Source
Cumminz
Cummins ISB4.5 CM2150 Fault Code: 3597 PID: SID 254 SPN: 3360 FMI: 9 Aftertreatment Diesel Exhaust Fluid Controller – Abnormal Update Rate.
Cumminz
CAT 3406E (Prefix 5DS or 1LW) Fault Code: 29 PID: 30 SPN: FMI: 8 PTO Throttle signal invalid
3406E (Prefix 5DS or 1LW)
Detroit DD13 GHG14 (2014-16) Fault Code: SPN 511403 FMI 5 (CPC) Air1 Message (Air Supply Pressure) is Missing from Second Source Address
DD13 GHG14 (2014-16)

Volvo All Engines (2010 Emissions) Fault Code: SPN 631 FMI 2 PID: PSID 124 Calibration memory

CAT ET 2026 Diagnostic Software

DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026

DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025

John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible

Volvo PROSIS Offline 2019 Parts Catalog Installation Service

Navistar Engine Diagnostics (NEDS) 2023

Freightliner ServiceLink 4.9.6

Cummins ISB CM850 (2003-06) Fault Code: 595 (ISB) PID: 103 SPN: 103 FMI: 0 Turbocharger Number 1 speed high – warning level. High turbocharger speed has been detected.

Detroit DD15 EPA10 (2010-13) Fault Code: SPN 2631 FMI 3 (MCM, ACM) Intake Manifold Pressure Sensor Circuit Failed High

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 653 FMI 4 (MCM) Injector Cylinder #3 Needle Control Valve Abnormal Operation (MIN)

PACCAR PX-9 CM2350 (2013-17) Fault Code:241 PID:84 SPN:84 FMI:2 Wheel-Based Vehicle Speed – Data Erratic, Intermittent, or Incorrect

Detroit DD15 EPA10 (2010-13) Fault Code: SPN 157 FMI 16 (MCM) Fuel Rail Pressure Too Low

Detroit DD15 EPA07 (2007-09) Fault Code: SPN 625 FMI 9 (MCM) No Data Received from Engine CAN Link

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 651 FMI 7 (MCM) Injector Cylinder #1 Needle Control Valve Stuck Open

Volvo All Engines (2013 Emissions) Fault Code: P02D100 PID: EMS Cylinder 3 fuel Injector Offset Learning At Max Limit

Cummins ISM CM870 (2003-06) Fault Code: 2376 PID: P412 SPN: 412 FMI: 4/4 Recirculated Exhaust Gas Temperature Sensor Circuit – Voltage Below Normal or Shorted to Low Source. Low signal voltage detected at EGR temperature circuit.

Cummins ISB6.7 CM2350 (2013-17) Fault Code: 3541 PID: SPN: 51 FMI: 4 Engine Intake Throttle ACtuator Position Sensor Circuit- Voltage Below Normal or Shorted to Low Source

Cummins ISX12 CM2250 (2010-12) Fault Code: 1879 PID: SID 324 SPN: 3251 FMI: 3 Aftertreatment Diesel Particulate Filter Differential Pressure Sensor Circuit- Voltage above Normal or Shorted to High Source

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 520267 FMI 15 (MCM) Motor Control Module Engine Hours Data Erratic, Intermittent or Incorrect

Cummins ISB6.7 CM2350 (2013-17) Fault Code: 5792 PID: SPN: 7321 FMI: 4 Aftertreatment 1 Particulate Sensor Heater High Side Driver Circuit – Voltage Below Normal or Shorted to Low Source. An internal circuit error has been detected by the aftertreatment particulate matter sensor.

Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 123 PID: PID 102 SPN: 102 FMI: 4 Intake Manifold 1 Pressure Sensor Circuit- Voltage Below Normal or Shorted to Low Source

Cummins X15 CM2450 X124B (2018 & Newer) Fault Code: 7222 PID: SPN: 1112 FMI: 3/3 Engine Brake Actuator Driver 3 Circuit – Voltage Above Normal or Shorted to High Source

Cummins ISB4.5 CM2150 Fault Code: 3597 PID: SID 254 SPN: 3360 FMI: 9 Aftertreatment Diesel Exhaust Fluid Controller – Abnormal Update Rate.

CAT 3406E (Prefix 5DS or 1LW) Fault Code: 29 PID: 30 SPN: FMI: 8 PTO Throttle signal invalid

Detroit DD13 GHG14 (2014-16) Fault Code: SPN 511403 FMI 5 (CPC) Air1 Message (Air Supply Pressure) is Missing from Second Source Address

Store

About

Features

Follow Us

Volvo All Engines (2010 Emissions) Fault Code: SPN 631 FMI 2 PID: PSID 124 Calibration memory

CAT ET 2026 Diagnostic Software

DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026

DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025

John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible

Volvo PROSIS Offline 2019 Parts Catalog Installation Service

Navistar Engine Diagnostics (NEDS) 2023

Freightliner ServiceLink 4.9.6

Related products

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 3717 PID: SPN: 3226 FMI: 13 Aftertreatment Outlet Nox Sensor- Out of Calibration

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 4431 PID: SPN: 3360 FMI: 13 Aftertreatment Diesel Exhaust Fluid Controller- Out of Calibration

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 1691 PID: SPN: 3250 FMI: 13 Catalyst Efficiency – Out of Calibration. The temperature increase across the aftertreatment diesel oxidation catalyst is lower than expected.

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 432 PID: SID 230 SPN: 558 FMI: 13 Accelerator Pedal or Lever Idle Validation Circuit – Out of Calibration. Voltage at idle validation on-idle and off-idle circuit does not match accelerator pedal position.

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 2449 PID: SID 027 SPN: 641 FMI: 13 VGT Actuator Controller – Out of Calibration. The VGT has failed the automatic calibration procedure at initial key-ON.

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 1898 PID: SID 27 SPN: 641 FMI: 13 VGT Actuator Controller- Out of Calibration

PACCAR PX-8 CM2150 (2007-09) Fault Code: 2635 PID: SID 027 SPN: 641 FMI: 11 VGT Actuator Driver Circuit – Condition Exists. A calibration mismatch between the VGT actuator and the ECM has been detected.

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 2765 PID: SPN: 2797 FMI: 13 Engine Injector Bank 1 Barcodes – Out of Calibration. Invalid injector barcode information has been entered.

Cummins ISX CM870 (2003-06) Fault Code: 2348 PID: 27 SPN: 27 FMI: 13/13 EGR Valve Self Calibration. EGR valve failed automatic self calibration procedure.

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 3718 PID: SPN: 3216 FMI: 13 Aftertreatment Intake Nox- Out of Calibration

PACCAR PX-6 CM2150 (2007-09) Fault Code: 1896 PID: SID 146 SPN: 2791 FMI: 13 EGR Valve Controller – Out of Calibration. The EGR valve has failed the automatic calibration procedure at initial key-on.

Cummins ISB CM850 (2003-06) Fault Code: 595 (ISB) PID: 103 SPN: 103 FMI: 0 Turbocharger Number 1 speed high – warning level. High turbocharger speed has been detected.

Detroit DD15 EPA10 (2010-13) Fault Code: SPN 2631 FMI 3 (MCM, ACM) Intake Manifold Pressure Sensor Circuit Failed High

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 653 FMI 4 (MCM) Injector Cylinder #3 Needle Control Valve Abnormal Operation (MIN)

PACCAR PX-9 CM2350 (2013-17) Fault Code:241 PID:84 SPN:84 FMI:2 Wheel-Based Vehicle Speed – Data Erratic, Intermittent, or Incorrect

Detroit DD15 EPA10 (2010-13) Fault Code: SPN 157 FMI 16 (MCM) Fuel Rail Pressure Too Low

Detroit DD15 EPA07 (2007-09) Fault Code: SPN 625 FMI 9 (MCM) No Data Received from Engine CAN Link

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 651 FMI 7 (MCM) Injector Cylinder #1 Needle Control Valve Stuck Open

Volvo All Engines (2013 Emissions) Fault Code: P02D100 PID: EMS Cylinder 3 fuel Injector Offset Learning At Max Limit

Cummins ISM CM870 (2003-06) Fault Code: 2376 PID: P412 SPN: 412 FMI: 4/4 Recirculated Exhaust Gas Temperature Sensor Circuit – Voltage Below Normal or Shorted to Low Source. Low signal voltage detected at EGR temperature circuit.

Cummins ISB6.7 CM2350 (2013-17) Fault Code: 3541 PID: SPN: 51 FMI: 4 Engine Intake Throttle ACtuator Position Sensor Circuit- Voltage Below Normal or Shorted to Low Source

Cummins ISX12 CM2250 (2010-12) Fault Code: 1879 PID: SID 324 SPN: 3251 FMI: 3 Aftertreatment Diesel Particulate Filter Differential Pressure Sensor Circuit- Voltage above Normal or Shorted to High Source

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 520267 FMI 15 (MCM) Motor Control Module Engine Hours Data Erratic, Intermittent or Incorrect

Cummins ISB6.7 CM2350 (2013-17) Fault Code: 5792 PID: SPN: 7321 FMI: 4 Aftertreatment 1 Particulate Sensor Heater High Side Driver Circuit – Voltage Below Normal or Shorted to Low Source. An internal circuit error has been detected by the aftertreatment particulate matter sensor.

Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 123 PID: PID 102 SPN: 102 FMI: 4 Intake Manifold 1 Pressure Sensor Circuit- Voltage Below Normal or Shorted to Low Source

Cummins X15 CM2450 X124B (2018 & Newer) Fault Code: 7222 PID: SPN: 1112 FMI: 3/3 Engine Brake Actuator Driver 3 Circuit – Voltage Above Normal or Shorted to High Source

Cummins ISB4.5 CM2150 Fault Code: 3597 PID: SID 254 SPN: 3360 FMI: 9 Aftertreatment Diesel Exhaust Fluid Controller – Abnormal Update Rate.

CAT 3406E (Prefix 5DS or 1LW) Fault Code: 29 PID: 30 SPN: FMI: 8 PTO Throttle signal invalid

Detroit DD13 GHG14 (2014-16) Fault Code: SPN 511403 FMI 5 (CPC) Air1 Message (Air Supply Pressure) is Missing from Second Source Address

Store

About

Features

Follow Us