Volvo All Engines (2010 Emissions) Fault Code: SPN 631 FMI 7 PID: PSID 124 Calibration memory

Category All Engines (2010 Emissions) Tags 124, 2010, 631, 7, All, Calibration, CodeSPN, Emissions, Engines, Fault, FMI, Memory, PIDPSID, Volvo

Conditions for diagnostic trouble code (DTC):
1) Software error

Observable symptoms
1) Engine cannot be started

Probable cause
1) ACM EEPROM

CAT
CAT ET 2026 Diagnostic Software
$110.00 Add to cart
Detroit
DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026
$120.00 Add to cart
Detroit
DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025
$110.00 Add to cart
John Deere
John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible
$420.00 Add to cart

Isuzu US-IDSS 2024 Diagnostic
ISUZU $220.00
Isuzu E-IDSS Diagnostic Service System 04.2022 ( 1 PC )
ISUZU $126.00
HINO EPC 2018 TRUCKS / BUSES 2018 EPC PARTS CATALOG
Hino $85.00

Detroit DD16 EPA10 (2010-13) Fault Code: SPN 4357 FMI 5 (ACM) Line Heater 4 Open Circuit
DD16 EPA10 (2010-13)
CAT 3406E (Prefix 1MM or 2WS) Fault Code: 65 PID: SPN: 174 FMI: 0 High Fuel Temperature Warning
3406E (Prefix 1MM or 2WS)
Cummins ISB CM850 (2003-06) Fault Code: 2346 (ISB) PID: SPN: 2789 FMI: 15 Exhaust gas temperature – data above normal. High exhaust temperature has been calculated by the electronic control system.
Cumminz
Volvo All Engines (2013 Emissions) Fault Code: P020456 PID: EMS Cylinder 4 Injector “A”
All Engines (2013 Emissions)
Detroit DD15 GHG14 (2014-16) Fault Code: SPN 5359 FMI 16 (MCM) Cylinder #2 Engine Smoothness Control/Quantity Low
DD15 GHG14 (2014-16)
Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 2222 (3 Wire) PID: PID 96 SPN: 96 FMI: 3 Fuel Level (Main Tank) Sensor Circuit- Voltage Above Normal or Shorted to High Source
Cumminz
Cummins ISL CM850 (2003-06) Fault Code: 2293 PID: SPN: FMI: 18 Fuel inlet meter device flow demand lower than expected – data valid but below normal operational range – moderately severe level. The flow demand is lower than expected.
Cumminz
Cummins X15 CM2450 X124B (2018 & Newer) Fault Code: 5881 PID: SPN: 3464 FMI: 4 Electronic Throttle Control Actuator Driver Circuit- Voltage Below Normal or Shorted to Low Source
Cumminz
Volvo All Engines (2013 Emissions) Fault Code: P20B173 PID: ACM Reductant Heater Coolant Control Valve Control
All Engines (2013 Emissions)
Volvo All Engines (2010 Emissions) Fault Code: SPN 4376 FMI 5 PID: PSID 105 Aftertreatment Diesel Exhaust Fluid Pump (DEF) Return Valve
All Engines (2010 Emissions)
Cummins ISB4.5 CM2150 Fault Code: 3418 PID: SPN: 191 FMI: 19 Transmission Output Shaft Speed – Received Network Data In Error.
Cumminz
Cummins ISM CM875 (2003-06) Fault Code: 242 PID: P084 SPN: 84 FMI: 10/10 Wheel-Based Vehicle Speed Sensor Circuit Tampering Has Been Detected – Abnormal Rate of Change. Signal indicates an intermittent connection or vehicle speed sensor (VSS) tampering.
Cumminz
Detroit DD13 EPA10 (2010-13) Fault Code: SPN 636 FMI 3 (MCM) Crankshaft Position Sensor has and Open Circuit
DD13 EPA10 (2010-13)
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 625 FMI 4 (CPC) ECAN Link Circuit Failure
DD16 GHG14 (2014-16)
Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID211 FMI 4 Sensor Supply Voltage #2 (+5V DC)
D12D AE E3 (Tier 3)
Detroit DD13 GHG14 (2014-16) Fault Code: SPN 191 FMI 13 (CPC) This Diagnostic is Typically the Transmission Output Sped Shaft Signal is Missing
DD13 GHG14 (2014-16)
Detroit DD16 EPA07 (2007-09) Fault Code: SPN 656 FMI 14 (MCM) Injector Cylinder #6 Needle Control Valve Abnormal Operation
DD16 EPA07 (2007-09)
Cummins X15 CM2450 X124B (2018 & Newer) Fault Code: 6644 PID: SPN: 5569 FMI: 4 Aftertreatment 1 Diesel Particulate Filter 1 Soot Sensor ECU Internal Temperature 2 Circuit- Voltage Below Normal or Shorted to low Source
Cumminz

Volvo All Engines (2010 Emissions) Fault Code: SPN 631 FMI 7 PID: PSID 124 Calibration memory

CAT ET 2026 Diagnostic Software

DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026

DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025

John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible

Isuzu US-IDSS 2024 Diagnostic

Isuzu E-IDSS Diagnostic Service System 04.2022 ( 1 PC )

HINO EPC 2018 TRUCKS / BUSES 2018 EPC PARTS CATALOG

Detroit DD16 EPA10 (2010-13) Fault Code: SPN 4357 FMI 5 (ACM) Line Heater 4 Open Circuit

CAT 3406E (Prefix 1MM or 2WS) Fault Code: 65 PID: SPN: 174 FMI: 0 High Fuel Temperature Warning

Cummins ISB CM850 (2003-06) Fault Code: 2346 (ISB) PID: SPN: 2789 FMI: 15 Exhaust gas temperature – data above normal. High exhaust temperature has been calculated by the electronic control system.

Volvo All Engines (2013 Emissions) Fault Code: P020456 PID: EMS Cylinder 4 Injector “A”

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 5359 FMI 16 (MCM) Cylinder #2 Engine Smoothness Control/Quantity Low

Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 2222 (3 Wire) PID: PID 96 SPN: 96 FMI: 3 Fuel Level (Main Tank) Sensor Circuit- Voltage Above Normal or Shorted to High Source

Cummins ISL CM850 (2003-06) Fault Code: 2293 PID: SPN: FMI: 18 Fuel inlet meter device flow demand lower than expected – data valid but below normal operational range – moderately severe level. The flow demand is lower than expected.

Cummins X15 CM2450 X124B (2018 & Newer) Fault Code: 5881 PID: SPN: 3464 FMI: 4 Electronic Throttle Control Actuator Driver Circuit- Voltage Below Normal or Shorted to Low Source

Volvo All Engines (2013 Emissions) Fault Code: P20B173 PID: ACM Reductant Heater Coolant Control Valve Control

Volvo All Engines (2010 Emissions) Fault Code: SPN 4376 FMI 5 PID: PSID 105 Aftertreatment Diesel Exhaust Fluid Pump (DEF) Return Valve

Cummins ISB4.5 CM2150 Fault Code: 3418 PID: SPN: 191 FMI: 19 Transmission Output Shaft Speed – Received Network Data In Error.

Cummins ISM CM875 (2003-06) Fault Code: 242 PID: P084 SPN: 84 FMI: 10/10 Wheel-Based Vehicle Speed Sensor Circuit Tampering Has Been Detected – Abnormal Rate of Change. Signal indicates an intermittent connection or vehicle speed sensor (VSS) tampering.

Detroit DD13 EPA10 (2010-13) Fault Code: SPN 636 FMI 3 (MCM) Crankshaft Position Sensor has and Open Circuit

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 625 FMI 4 (CPC) ECAN Link Circuit Failure

Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID211 FMI 4 Sensor Supply Voltage #2 (+5V DC)

Detroit DD13 GHG14 (2014-16) Fault Code: SPN 191 FMI 13 (CPC) This Diagnostic is Typically the Transmission Output Sped Shaft Signal is Missing

Detroit DD16 EPA07 (2007-09) Fault Code: SPN 656 FMI 14 (MCM) Injector Cylinder #6 Needle Control Valve Abnormal Operation

Cummins X15 CM2450 X124B (2018 & Newer) Fault Code: 6644 PID: SPN: 5569 FMI: 4 Aftertreatment 1 Diesel Particulate Filter 1 Soot Sensor ECU Internal Temperature 2 Circuit- Voltage Below Normal or Shorted to low Source

Store

About

Features

Follow Us

Volvo All Engines (2010 Emissions) Fault Code: SPN 631 FMI 7 PID: PSID 124 Calibration memory

CAT ET 2026 Diagnostic Software

DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026

DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025

John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible

Isuzu US-IDSS 2024 Diagnostic

Isuzu E-IDSS Diagnostic Service System 04.2022 ( 1 PC )

HINO EPC 2018 TRUCKS / BUSES 2018 EPC PARTS CATALOG

Related products

PACCAR PX-8 CM2150 (2007-09) Fault Code: 2635 PID: SID 027 SPN: 641 FMI: 11 VGT Actuator Driver Circuit – Condition Exists. A calibration mismatch between the VGT actuator and the ECM has been detected.

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 1896 PID: SID 146 SPN: 2791 FMI: 13 EGR Valve Controller- Out of Calibration

Cummins ISB4.5 CM2150 Fault Code: 3697 PID: SID 254 SPN: 630 FMI: 12 Engine Control Module Calibration Memory – Bad Intelligent Device or Component.

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 432 PID: SID 230 SPN: 558 FMI: 13 Accelerator Pedal or Lever Idle Validation Circuit – Out of Calibration. Voltage at idle validation on-idle and off-idle circuit does not match accelerator pedal position.

PACCAR PX-8 CM2150 (2007-09) Fault Code: 1896 PID: SID 146 SPN: 2791 FMI: 13 EGR Valve Controller – Out of Calibration. The EGR valve has failed the automatic calibration procedure at initial key-on.

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 2449 PID: SID 027 SPN: 641 FMI: 13 VGT Actuator Controller – Out of Calibration. The VGT has failed the automatic calibration procedure at initial key-ON.

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 4431 PID: SPN: 3360 FMI: 13 Aftertreatment Diesel Exhaust Fluid Controller- Out of Calibration

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 3718 PID: SPN: 3216 FMI: 13 Aftertreatment Intake Nox- Out of Calibration

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 3697 PID: SID 254 SPN: 630 FMI: 12 Engine Control Module Calibration Memory- Bad Intelligent Device or Component

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 2765 PID: SID 392 SPN: 2797 FMI: 13 Engine Injector Bank 1 Barcodes- Out of Calibration

Cummins ISB4.5 CM2150 Fault Code: 346 PID: 253 SPN: 630 FMI: 12 Engine Control Module Calibration Memory Software – Bad Intelligent Device or Component.

Detroit DD16 EPA10 (2010-13) Fault Code: SPN 4357 FMI 5 (ACM) Line Heater 4 Open Circuit

CAT 3406E (Prefix 1MM or 2WS) Fault Code: 65 PID: SPN: 174 FMI: 0 High Fuel Temperature Warning

Cummins ISB CM850 (2003-06) Fault Code: 2346 (ISB) PID: SPN: 2789 FMI: 15 Exhaust gas temperature – data above normal. High exhaust temperature has been calculated by the electronic control system.

Volvo All Engines (2013 Emissions) Fault Code: P020456 PID: EMS Cylinder 4 Injector “A”

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 5359 FMI 16 (MCM) Cylinder #2 Engine Smoothness Control/Quantity Low

Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 2222 (3 Wire) PID: PID 96 SPN: 96 FMI: 3 Fuel Level (Main Tank) Sensor Circuit- Voltage Above Normal or Shorted to High Source

Cummins ISL CM850 (2003-06) Fault Code: 2293 PID: SPN: FMI: 18 Fuel inlet meter device flow demand lower than expected – data valid but below normal operational range – moderately severe level. The flow demand is lower than expected.

Cummins X15 CM2450 X124B (2018 & Newer) Fault Code: 5881 PID: SPN: 3464 FMI: 4 Electronic Throttle Control Actuator Driver Circuit- Voltage Below Normal or Shorted to Low Source

Volvo All Engines (2013 Emissions) Fault Code: P20B173 PID: ACM Reductant Heater Coolant Control Valve Control

Volvo All Engines (2010 Emissions) Fault Code: SPN 4376 FMI 5 PID: PSID 105 Aftertreatment Diesel Exhaust Fluid Pump (DEF) Return Valve

Cummins ISB4.5 CM2150 Fault Code: 3418 PID: SPN: 191 FMI: 19 Transmission Output Shaft Speed – Received Network Data In Error.

Cummins ISM CM875 (2003-06) Fault Code: 242 PID: P084 SPN: 84 FMI: 10/10 Wheel-Based Vehicle Speed Sensor Circuit Tampering Has Been Detected – Abnormal Rate of Change. Signal indicates an intermittent connection or vehicle speed sensor (VSS) tampering.

Detroit DD13 EPA10 (2010-13) Fault Code: SPN 636 FMI 3 (MCM) Crankshaft Position Sensor has and Open Circuit

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 625 FMI 4 (CPC) ECAN Link Circuit Failure

Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID211 FMI 4 Sensor Supply Voltage #2 (+5V DC)

Detroit DD13 GHG14 (2014-16) Fault Code: SPN 191 FMI 13 (CPC) This Diagnostic is Typically the Transmission Output Sped Shaft Signal is Missing

Detroit DD16 EPA07 (2007-09) Fault Code: SPN 656 FMI 14 (MCM) Injector Cylinder #6 Needle Control Valve Abnormal Operation

Cummins X15 CM2450 X124B (2018 & Newer) Fault Code: 6644 PID: SPN: 5569 FMI: 4 Aftertreatment 1 Diesel Particulate Filter 1 Soot Sensor ECU Internal Temperature 2 Circuit- Voltage Below Normal or Shorted to low Source

Store

About

Features

Follow Us