Volvo All Engines (2010 Emissions) Fault Code: SPN 631 FMI 8 PID: PSID 124 Calibration memory

Category All Engines (2010 Emissions) Tags 124, 2010, 631, 8, All, Calibration, CodeSPN, Emissions, Engines, Fault, FMI, Memory, PIDPSID, Volvo

Conditions for diagnostic trouble code (DTC):
1) Internal fault in electronic control unit (ECU)
2) Incorrect self test in the engine control module (ECM)

Observable symptoms
1) Engine does not start

Probable cause
1) Aftertreatment Control Module (ACM)

CAT
CAT ET 2026 Diagnostic Software
$110.00 Add to cart
Detroit
DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026
$120.00 Add to cart
Detroit
DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025
$110.00 Add to cart
John Deere
John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible
$420.00 Add to cart

Perkins EST 2016C Electronic Service Tool
Perkins $50.00
PACCAR Engine Analyzer v1.3.0.6
PACCAR $55.00
International Truck ISIS – Oncommand Service Information Q4.2020 [04.2020]
Navistar $85.00

Detroit DD13 EPA07 (2007-09) Fault Code: SPN 600 FMI 19 (CPC) J1939 Cruise Control Coast Switch Signal from Source #1, #2 or #3 is Erratic
DD13 EPA07 (2007-09)
Cummins X15 CM2350 X116B Performance Series (2018 & Newer) Fault Code: 272 PID: SID 126 SPN: 1347 FMI: 3 Engine Fuel Pump PRessurizing Assembly 1 Circuit- Voltage Above Normal or Shorted to High Source
Cumminz
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 1327 FMI 31 (MCM) Idle Smoothness Control/Cylinder #5 Misfire at Idle
DD16 GHG14 (2014-16)
Cummins X15 CM2450 X124B (2018 & Newer) Fault Code: 4585 PID: SPN: 4792 FMI: 14 Aftertreatment 1 SCR Catalyst System- Special Instructions
Cumminz
Volvo All Engines (2017 Emissions) Fault Code: P040964 PID: EMS EGR Differential Pressure Sensor
All Engines (2017 Emissions)
Cummins ISB CM850 (2003-06) Fault Code: 285 PID: SID 231 SPN: 639 FMI: 9 SAE J1939 Multiplexing PGN Timeout Error – Abnormal Update Rate. The Cummins? ECM did not receive a multiplexed message from an OEM VECU or SIM within the time limit or did not receive it at all.
Cumminz
Cummins X15 CM2350 X116B Performance Series (2018 & Newer) Fault Code: 5881 PID: SPN: 3464 FMI: 4 Electronic Throttle Control Actuator Driver Circuit- Voltage Below Normal or Shorted to Low Source
Cumminz
Cummins ISM CM875 (2003-06) Fault Code: 196 (2 wire) PID: P111 SPN: 111 FMI: 4/4 Coolant Level Sensor 1 Circuit – Voltage Below Normal or Shorted to Low Source. Low signal voltage detected at the engine coolant level circuit.
Cumminz
Cummins ISX12 CM2250 (2010-12) Fault Code: 3256 PID: SPN: 3246 FMI: 15 Aftertreatment Diesel Particulate Filter Outlet Temperature- Data Valid But Above Normal Operating Range- Least Severe level
Cumminz
Detroit DD13 EPA07 (2007-09) Fault Code: SPN 171 FMI 14 (CPC) J1587 Ambient Air Temperature Sensor Data Not Received this Ignition Cycle
DD13 EPA07 (2007-09)
PACCAR MX (2004 Emissions) Fault Code: P1722 BPV Control – Data Erratic, Intermittent, or Incorrect
MX (2004 Emissions)
Volvo All Engines (2013 Emissions) Fault Code: P02CC00 PID: EMS Cylinder 1 Fuel Injector Offset Learning at Min Limit
All Engines (2013 Emissions)
Eaton Fuller Advantage (2017) Fault Code: 65 PID: 190 SPN: FMI: 2 ECA Speed Sensor: Data Erratic
DTC TRUCKS
Volvo Engine D13F Fault Code: PID 175 FMI 5 Engine Oil Temperature
D13F
PACCAR MX (2004 Emissions) Fault Code: P3421 MX Engine Brake Solenoid Valve Cylinder 3 – Current Too Low or Open Circuit on ECU (D420) Pin (A24)
MX (2004 Emissions)
Detroit DD15 GHG14 (2014-16) Fault Code: SPN 630 FMI 13 (CPC) Selective Catalytic Reduction Number Out of Range
DD15 GHG14 (2014-16)
Detroit DD13 GHG14 (2014-16) Fault Code: SPN 4041 FMI 0 (CPC) Common Powertrain Controller Internal Failure
DD13 GHG14 (2014-16)
Volvo All Engines (2013 Emissions) Fault Code: P020211 PID: EMS Cylinder 2 Injector “A”
All Engines (2013 Emissions)

Volvo All Engines (2010 Emissions) Fault Code: SPN 631 FMI 8 PID: PSID 124 Calibration memory

CAT ET 2026 Diagnostic Software

DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026

DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025

John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible

Perkins EST 2016C Electronic Service Tool

PACCAR Engine Analyzer v1.3.0.6

International Truck ISIS – Oncommand Service Information Q4.2020 [04.2020]

Detroit DD13 EPA07 (2007-09) Fault Code: SPN 600 FMI 19 (CPC) J1939 Cruise Control Coast Switch Signal from Source #1, #2 or #3 is Erratic

Cummins X15 CM2350 X116B Performance Series (2018 & Newer) Fault Code: 272 PID: SID 126 SPN: 1347 FMI: 3 Engine Fuel Pump PRessurizing Assembly 1 Circuit- Voltage Above Normal or Shorted to High Source

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 1327 FMI 31 (MCM) Idle Smoothness Control/Cylinder #5 Misfire at Idle

Cummins X15 CM2450 X124B (2018 & Newer) Fault Code: 4585 PID: SPN: 4792 FMI: 14 Aftertreatment 1 SCR Catalyst System- Special Instructions

Volvo All Engines (2017 Emissions) Fault Code: P040964 PID: EMS EGR Differential Pressure Sensor

Cummins ISB CM850 (2003-06) Fault Code: 285 PID: SID 231 SPN: 639 FMI: 9 SAE J1939 Multiplexing PGN Timeout Error – Abnormal Update Rate. The Cummins? ECM did not receive a multiplexed message from an OEM VECU or SIM within the time limit or did not receive it at all.

Cummins X15 CM2350 X116B Performance Series (2018 & Newer) Fault Code: 5881 PID: SPN: 3464 FMI: 4 Electronic Throttle Control Actuator Driver Circuit- Voltage Below Normal or Shorted to Low Source

Cummins ISM CM875 (2003-06) Fault Code: 196 (2 wire) PID: P111 SPN: 111 FMI: 4/4 Coolant Level Sensor 1 Circuit – Voltage Below Normal or Shorted to Low Source. Low signal voltage detected at the engine coolant level circuit.

Cummins ISX12 CM2250 (2010-12) Fault Code: 3256 PID: SPN: 3246 FMI: 15 Aftertreatment Diesel Particulate Filter Outlet Temperature- Data Valid But Above Normal Operating Range- Least Severe level

Detroit DD13 EPA07 (2007-09) Fault Code: SPN 171 FMI 14 (CPC) J1587 Ambient Air Temperature Sensor Data Not Received this Ignition Cycle

PACCAR MX (2004 Emissions) Fault Code: P1722 BPV Control – Data Erratic, Intermittent, or Incorrect

Volvo All Engines (2013 Emissions) Fault Code: P02CC00 PID: EMS Cylinder 1 Fuel Injector Offset Learning at Min Limit

Eaton Fuller Advantage (2017) Fault Code: 65 PID: 190 SPN: FMI: 2 ECA Speed Sensor: Data Erratic

Volvo Engine D13F Fault Code: PID 175 FMI 5 Engine Oil Temperature

PACCAR MX (2004 Emissions) Fault Code: P3421 MX Engine Brake Solenoid Valve Cylinder 3 – Current Too Low or Open Circuit on ECU (D420) Pin (A24)

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 630 FMI 13 (CPC) Selective Catalytic Reduction Number Out of Range

Detroit DD13 GHG14 (2014-16) Fault Code: SPN 4041 FMI 0 (CPC) Common Powertrain Controller Internal Failure

Volvo All Engines (2013 Emissions) Fault Code: P020211 PID: EMS Cylinder 2 Injector “A”

Store

About

Features

Follow Us

Volvo All Engines (2010 Emissions) Fault Code: SPN 631 FMI 8 PID: PSID 124 Calibration memory

CAT ET 2026 Diagnostic Software

DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026

DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025

John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible

Perkins EST 2016C Electronic Service Tool

PACCAR Engine Analyzer v1.3.0.6

International Truck ISIS – Oncommand Service Information Q4.2020 [04.2020]

Related products

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 1691 PID: SPN: 3250 FMI: 13 Catalyst Efficiency – Out of Calibration. The temperature increase across the aftertreatment diesel oxidation catalyst is lower than expected.

PACCAR PX-8 CM2150 (2007-09) Fault Code: 2635 PID: SID 027 SPN: 641 FMI: 11 VGT Actuator Driver Circuit – Condition Exists. A calibration mismatch between the VGT actuator and the ECM has been detected.

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 2638 PID: SPN: 3050 FMI: 13 Catalyst Efficiency – Out of Calibration. The temperature increase across the aftertreatment diesel oxidation catalyst is lower than expected.

PACCAR PX-6 CM2150 (2007-09) Fault Code: 2635 PID: SID 027 SPN: 641 FMI: 11 VGT Actuator Driver Circuit – Condition Exists. A calibration mismatch between the VGT actuator and the ECM has been detected.

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 432 PID: SID 230 SPN: 558 FMI: 13 Accelerator Pedal or Lever Idle Validation Circuit – Out of Calibration. Voltage at idle validation on-idle and off-idle circuit does not match accelerator pedal position.

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 2449 PID: SID 27 SPN: 641 FMI: 13 VGT Actuator Controller- Out of Calibration

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 1896 PID: SID 146 SPN: 2791 FMI: 13 EGR Valve Controller- Out of Calibration

Cummins ISM CM870 (2003-06) Fault Code: 2348 PID: 27 SPN: 27 FMI: 13/13 EGR Valve Self Calibration. EGR valve failed automatic self calibration procedure.

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 3718 PID: SPN: 3216 FMI: 13 Aftertreatment Intake Nox- Out of Calibration

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 346 (MD) PID: SID 253 SPN: 630 FMI: 12 Engine Control Module Calibration Memory Software- Bad Intelligent Device or Component

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 2635 PID: SID 027 SPN: 641 FMI: 11 VGT Actuator Driver Circuit – Condition Exists. A calibration mismatch between the VGT actuator and the ECM has been detected.

Detroit DD13 EPA07 (2007-09) Fault Code: SPN 600 FMI 19 (CPC) J1939 Cruise Control Coast Switch Signal from Source #1, #2 or #3 is Erratic

Cummins X15 CM2350 X116B Performance Series (2018 & Newer) Fault Code: 272 PID: SID 126 SPN: 1347 FMI: 3 Engine Fuel Pump PRessurizing Assembly 1 Circuit- Voltage Above Normal or Shorted to High Source

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 1327 FMI 31 (MCM) Idle Smoothness Control/Cylinder #5 Misfire at Idle

Cummins X15 CM2450 X124B (2018 & Newer) Fault Code: 4585 PID: SPN: 4792 FMI: 14 Aftertreatment 1 SCR Catalyst System- Special Instructions

Volvo All Engines (2017 Emissions) Fault Code: P040964 PID: EMS EGR Differential Pressure Sensor

Cummins ISB CM850 (2003-06) Fault Code: 285 PID: SID 231 SPN: 639 FMI: 9 SAE J1939 Multiplexing PGN Timeout Error – Abnormal Update Rate. The Cummins? ECM did not receive a multiplexed message from an OEM VECU or SIM within the time limit or did not receive it at all.

Cummins X15 CM2350 X116B Performance Series (2018 & Newer) Fault Code: 5881 PID: SPN: 3464 FMI: 4 Electronic Throttle Control Actuator Driver Circuit- Voltage Below Normal or Shorted to Low Source

Cummins ISM CM875 (2003-06) Fault Code: 196 (2 wire) PID: P111 SPN: 111 FMI: 4/4 Coolant Level Sensor 1 Circuit – Voltage Below Normal or Shorted to Low Source. Low signal voltage detected at the engine coolant level circuit.

Cummins ISX12 CM2250 (2010-12) Fault Code: 3256 PID: SPN: 3246 FMI: 15 Aftertreatment Diesel Particulate Filter Outlet Temperature- Data Valid But Above Normal Operating Range- Least Severe level

Detroit DD13 EPA07 (2007-09) Fault Code: SPN 171 FMI 14 (CPC) J1587 Ambient Air Temperature Sensor Data Not Received this Ignition Cycle

PACCAR MX (2004 Emissions) Fault Code: P1722 BPV Control – Data Erratic, Intermittent, or Incorrect

Volvo All Engines (2013 Emissions) Fault Code: P02CC00 PID: EMS Cylinder 1 Fuel Injector Offset Learning at Min Limit

Eaton Fuller Advantage (2017) Fault Code: 65 PID: 190 SPN: FMI: 2 ECA Speed Sensor: Data Erratic

Volvo Engine D13F Fault Code: PID 175 FMI 5 Engine Oil Temperature

PACCAR MX (2004 Emissions) Fault Code: P3421 MX Engine Brake Solenoid Valve Cylinder 3 – Current Too Low or Open Circuit on ECU (D420) Pin (A24)

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 630 FMI 13 (CPC) Selective Catalytic Reduction Number Out of Range

Detroit DD13 GHG14 (2014-16) Fault Code: SPN 4041 FMI 0 (CPC) Common Powertrain Controller Internal Failure

Volvo All Engines (2013 Emissions) Fault Code: P020211 PID: EMS Cylinder 2 Injector “A”

Store

About

Features

Follow Us