Volvo All Engines (2010 Emissions) Fault Code: SPN 3031 FMI 5 PID: PPID 274 Aftertreatment Diesel Exhaust Fluid (DEF) Tank temperature
Aftertreatment Control Module (ACM) monitors DEF tank temperature and uses it to control the Aftertreatment DEF Tank Heater valve to keep the DEF from freezing.
This temperature monitoring is also used to avoid stopped DEF dosing due to high DEF tank temperatures. If the DEF temperature is too high, reverse flow will be activated, if the temperature stays high for a short duration, a DTC is set.
Conditions for diagnostic trouble code (DTC):
1) Open circuit between Electronic Control Unit and Sensor
Observable symptoms
1) Engine de-rated
Probable cause
1) Connector
2) Wiring harness
3) Short circuit to higher voltage, Signal wire
4) Open circuit on signal wire
5) Open circuit, Ground wire
6) Aftertreatment diesel exhaust fluid (DEF) tank, Temperature Sensor
-
Detroit Diesel Diagnostic Link DDDL 8.0 PRO PROFESSIONAL Software trucks
Detroit $25.00Rated 0 out of 5
Related products
-
Detroit Diesel Diagnostic Link DDDL 8.0 PRO PROFESSIONAL Software trucks
Detroit $25.00Rated 0 out of 5
-
Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID70 FMI 5 Air Inlet Heater Driver #1
D12D AE E3 (Tier 3)Rated 0 out of 5 -
Detroit DD13 GHG14 (2014-16) Fault Code: SPN 520326 FMI 4 (ACM) Over Pressurized Diesel Exhaust Fluid (DEF) System
DD13 GHG14 (2014-16)Rated 0 out of 5 -
CAT 3406E (Prefix 5DS or 1LW) Fault Code: 46 PID: 100 SPN: FMI: 1 Low Oil Pressure Warning
3406E (Prefix 5DS or 1LW)Rated 0 out of 5 -
Detroit DD15 EPA10 (2010-13) Fault Code: SPN 523 FMI 19 (MCM, CPC) Transmission Current Gear Signal is Erratic
DD15 EPA10 (2010-13)Rated 0 out of 5 -
Volvo All Engines (2013 Emissions) Fault Code: P064200 PID: EMS Sensor Reference Voltage “A”
All Engines (2013 Emissions)Rated 0 out of 5 -
Volvo All Engines (2017 Emissions) Fault Code: P020F25 PID: EMS Cylinder 6 Injection Timing
All Engines (2017 Emissions)Rated 0 out of 5 -
Detroit DD16 EPA07 (2007-09) Fault Code: SPN 656 FMI 14 (MCM) Injector Cylinder #6 Needle Control Valve Abnormal Operation
DD16 EPA07 (2007-09)Rated 0 out of 5 -
Volvo All Engines (2017 Emissions) Fault Code: P204F93 PID: ACM SCR System Performance Dosing Failure
All Engines (2017 Emissions)Rated 0 out of 5 -
Volvo All Engines (2013 Emissions) Fault Code: P02E300 PID: EMS Diesel Intake Air Flow Control Circuit High
All Engines (2013 Emissions)Rated 0 out of 5 -
Detroit DD16 EPA10 (2010-13) Fault Code: SPN 175 FMI 3 (MCM) Engine Oil Temperature Circuit Failed High
DD16 EPA10 (2010-13)Rated 0 out of 5 -
Detroit DD15 EPA10 (2010-13) Fault Code: SPN 164 FMI 4 (MCM) Fuel Rail Pressure Sensor Circuit Failed Low (Short to Ground)
DD15 EPA10 (2010-13)Rated 0 out of 5