Volvo All Engines (2010 Emissions) Fault Code: SPN 3241 FMI 4 PID: Aftertreatment 1 Exhaust Gas Temperature 1 – moderately severe level

Category All Engines (2010 Emissions) Tags 1, 2010, 3241, 4, Aftertreatment, All, CodeSPN, Emissions, Engines, Exhaust, Fault, FMI, Gas, Level, Moderately, PID, Severe, Temperature, Volvo

Probable cause
1) Short circuit to ground, Signal wire
2) Connector
3) Faulty sensor, B97

CAT
CAT ET 2026 Diagnostic Software
$110.00 Add to cart
Detroit
DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026
$120.00 Add to cart
Detroit
DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025
$110.00 Add to cart
John Deere
John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible
$420.00 Add to cart

Hino DX3 1.22.10 2022 ( 1 PC )
Hino $96.00
Isuzu G-IDSS Global 2024 Diagnostic Software
ISUZU $220.00
Allison DOC Premium 2023
Allison $96.00

Cummins ISB4.5 CM2150 Fault Code: 3186 PID: SPN: 1623 FMI: 9 Tachograph Output Shaft Speed – Abnormal Update Rate.
Cumminz
Cummins ISB6.7 CM2350 (2013-17) Fault Code: 1658 PID: SPN: 1327 FMI: 31 Engine Misfire Cylinder 5- Condition Exists
Cumminz
Cummins ISX11.9 CM2250 (2010-12) Fault Code: 3715 PID: SPN: 188 FMI: 16 Engine Speed At Idle- Data Valid But Below Normal Operating Range- Moderately Severe Level
Cumminz
Cummins ISX12 CM2250 (2010-12) Fault Code: 3492 PID: SPN: 251 FMI: 10 Real-Time Clock- Abnormal Rate of Change
Cumminz
Cummins ISX CM870 (2003-06) Fault Code: 551 (NISS) PID: S230 SPN: 558 FMI: 4/4 Accelerator Pedal Idle Validation Circuit – data incorrect. No voltage detected simultaneously on both idle validation and off-idle validation switches.
Cumminz
Volvo All Engines (2004 Emissions) Fault Code: PID 85 FMI 9 Cruise Control Status
All Engines (2004 Emissions)
Detroit DD15 EPA10 (2010-13) Fault Code: SPN 655 FMI 6 (MCM) Injector Cylinder #5 Needle Control Valve Shorted Circuit
DD15 EPA10 (2010-13)
Cummins ISX11.9 CM2250 (2010-12) Fault Code: 324 PID: SID 3 SPN: 653 FMI: 5 Injector Sloenoid Driver Cylinder 3 Circuit- Current Below Normal or Open Circuit
Cumminz
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 654 FMI 4 (MCM) Injector Cylinder #4 Needle Control Valve Abnormal Operation (MIN)
DD16 GHG14 (2014-16)
Detroit DD15 EPA10 (2010-13) Fault Code: SPN 636 FMI 31 (MCM) Crankshaft Position Sensor – Error Detected
DD15 EPA10 (2010-13)
PACCAR MX (2004 Emissions) Fault Code: P102A Exhaust Gas Temperature After BPV – Voltage Too High or Short Circuit to Supply on ECU (D420) Pin (C11)
MX (2004 Emissions)
Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 6263 PID: SPN: 647 FMI: 3 Fan Control Circuit- Voltage Above Normal or Shorted to High Source
Cumminz
Volvo Engine D11L (Tier 4) Fault Code: SID 253 FMI 14 Calibration Memory EEPROM
D11L (Tier 4)
Volvo Engine D12D AE E3 (Tier 3) Fault Code: PID84 FMI 9 Road Speed
D12D AE E3 (Tier 3)
Volvo All Engines (2013 Emissions) Fault Code: P004591 PID: EMS Turbocharger/Supercharger Boost Control “A” Circuit / Open
All Engines (2013 Emissions)
Detroit DD13 GHG14 (2014-16) Fault Code: SPN 5246 FMI 16 (ACM) Regulatory Fault Ignored – Final Action Pending
DD13 GHG14 (2014-16)
PACCAR PX-6 CM2150 (2007-09) Fault Code: 2374 PID: 131 SPN: 1209 FMI: 4 Exhaust Gas Pressure Sensor Circuit – Voltage Below Normal or Shorted to Low Source. Low signal voltage detected at the exhaust gas pressure circuit.
DTC TRUCKS
Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 3223 PID: SPN: 3490 FMI: 4 Aftertreatment Purge Air Actuator Circuit- Voltage Below Normal or Shorted to Low Source
Cumminz

Volvo All Engines (2010 Emissions) Fault Code: SPN 3241 FMI 4 PID: Aftertreatment 1 Exhaust Gas Temperature 1 – moderately severe level

CAT ET 2026 Diagnostic Software

DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026

DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025

John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible

Hino DX3 1.22.10 2022 ( 1 PC )

Isuzu G-IDSS Global 2024 Diagnostic Software

Allison DOC Premium 2023

Cummins ISB4.5 CM2150 Fault Code: 3186 PID: SPN: 1623 FMI: 9 Tachograph Output Shaft Speed – Abnormal Update Rate.

Cummins ISB6.7 CM2350 (2013-17) Fault Code: 1658 PID: SPN: 1327 FMI: 31 Engine Misfire Cylinder 5- Condition Exists

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 3715 PID: SPN: 188 FMI: 16 Engine Speed At Idle- Data Valid But Below Normal Operating Range- Moderately Severe Level

Cummins ISX12 CM2250 (2010-12) Fault Code: 3492 PID: SPN: 251 FMI: 10 Real-Time Clock- Abnormal Rate of Change

Cummins ISX CM870 (2003-06) Fault Code: 551 (NISS) PID: S230 SPN: 558 FMI: 4/4 Accelerator Pedal Idle Validation Circuit – data incorrect. No voltage detected simultaneously on both idle validation and off-idle validation switches.

Volvo All Engines (2004 Emissions) Fault Code: PID 85 FMI 9 Cruise Control Status

Detroit DD15 EPA10 (2010-13) Fault Code: SPN 655 FMI 6 (MCM) Injector Cylinder #5 Needle Control Valve Shorted Circuit

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 324 PID: SID 3 SPN: 653 FMI: 5 Injector Sloenoid Driver Cylinder 3 Circuit- Current Below Normal or Open Circuit

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 654 FMI 4 (MCM) Injector Cylinder #4 Needle Control Valve Abnormal Operation (MIN)

Detroit DD15 EPA10 (2010-13) Fault Code: SPN 636 FMI 31 (MCM) Crankshaft Position Sensor – Error Detected

PACCAR MX (2004 Emissions) Fault Code: P102A Exhaust Gas Temperature After BPV – Voltage Too High or Short Circuit to Supply on ECU (D420) Pin (C11)

Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 6263 PID: SPN: 647 FMI: 3 Fan Control Circuit- Voltage Above Normal or Shorted to High Source

Volvo Engine D11L (Tier 4) Fault Code: SID 253 FMI 14 Calibration Memory EEPROM

Volvo Engine D12D AE E3 (Tier 3) Fault Code: PID84 FMI 9 Road Speed

Volvo All Engines (2013 Emissions) Fault Code: P004591 PID: EMS Turbocharger/Supercharger Boost Control “A” Circuit / Open

Detroit DD13 GHG14 (2014-16) Fault Code: SPN 5246 FMI 16 (ACM) Regulatory Fault Ignored – Final Action Pending

PACCAR PX-6 CM2150 (2007-09) Fault Code: 2374 PID: 131 SPN: 1209 FMI: 4 Exhaust Gas Pressure Sensor Circuit – Voltage Below Normal or Shorted to Low Source. Low signal voltage detected at the exhaust gas pressure circuit.

Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 3223 PID: SPN: 3490 FMI: 4 Aftertreatment Purge Air Actuator Circuit- Voltage Below Normal or Shorted to Low Source

Store

About

Features

Follow Us

Volvo All Engines (2010 Emissions) Fault Code: SPN 3241 FMI 4 PID: Aftertreatment 1 Exhaust Gas Temperature 1 – moderately severe level

CAT ET 2026 Diagnostic Software

DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026

DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025

John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible

Hino DX3 1.22.10 2022 ( 1 PC )

Isuzu G-IDSS Global 2024 Diagnostic Software

Allison DOC Premium 2023

Related products

Allison 1000 & 2000 Gen 5 Fault Code:P0974 Shift Solenoid 1 (SS1) Control Circuit – High

Allison 1000 & 2000 Gen 5 Fault Code:P2729 Pressure Control Solenoid 1 (PCS1) Control Circuit – Low

Allison 1000 & 2000 Gen 5 Fault Code:P0979 Shift Solenoid 3 (SS3) Control Circuit – Low

Allison 1000 & 2000 Gen 5 Fault Code:P2685 Actuator Supply Circuit Voltage 3 Low (HSD3)

Allison 1000 & 2000 Gen 5 Fault Code:P2669 Actuator Supply Voltage 2 Open

Allison 1000 & 2000 Gen 5 Fault Code:U0073 CAN Communication Bus 1 Off

Allison 1000 & 2000 Gen 5 Fault Code:P2684 Actuator Supply Circuit Voltage 3 Open (HSD3)

Allison 1000 & 2000 Gen 5 Fault Code:P2641 Torque Management Feedback Signal – LRTP

Allison 1000 & 2000 Gen 5 Fault Code:P0973 Shift Solenoid 1 (SS1) Control Circuit – Low

Allison 1000 & 2000 Gen 5 Fault Code:P2789 Clutch Adaptive Learning at Limit

Allison 1000 & 2000 Gen 5 Fault Code:U0100 Lost Communication With ECM A

Allison 1000 & 2000 Gen 5 Fault Code:P2670 Actuator Supply Voltage 2 (HSD2) – Low

Cummins ISB4.5 CM2150 Fault Code: 3186 PID: SPN: 1623 FMI: 9 Tachograph Output Shaft Speed – Abnormal Update Rate.

Cummins ISB6.7 CM2350 (2013-17) Fault Code: 1658 PID: SPN: 1327 FMI: 31 Engine Misfire Cylinder 5- Condition Exists

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 3715 PID: SPN: 188 FMI: 16 Engine Speed At Idle- Data Valid But Below Normal Operating Range- Moderately Severe Level

Cummins ISX12 CM2250 (2010-12) Fault Code: 3492 PID: SPN: 251 FMI: 10 Real-Time Clock- Abnormal Rate of Change

Cummins ISX CM870 (2003-06) Fault Code: 551 (NISS) PID: S230 SPN: 558 FMI: 4/4 Accelerator Pedal Idle Validation Circuit – data incorrect. No voltage detected simultaneously on both idle validation and off-idle validation switches.

Volvo All Engines (2004 Emissions) Fault Code: PID 85 FMI 9 Cruise Control Status

Detroit DD15 EPA10 (2010-13) Fault Code: SPN 655 FMI 6 (MCM) Injector Cylinder #5 Needle Control Valve Shorted Circuit

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 324 PID: SID 3 SPN: 653 FMI: 5 Injector Sloenoid Driver Cylinder 3 Circuit- Current Below Normal or Open Circuit

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 654 FMI 4 (MCM) Injector Cylinder #4 Needle Control Valve Abnormal Operation (MIN)

Detroit DD15 EPA10 (2010-13) Fault Code: SPN 636 FMI 31 (MCM) Crankshaft Position Sensor – Error Detected

PACCAR MX (2004 Emissions) Fault Code: P102A Exhaust Gas Temperature After BPV – Voltage Too High or Short Circuit to Supply on ECU (D420) Pin (C11)

Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 6263 PID: SPN: 647 FMI: 3 Fan Control Circuit- Voltage Above Normal or Shorted to High Source

Volvo Engine D11L (Tier 4) Fault Code: SID 253 FMI 14 Calibration Memory EEPROM

Volvo Engine D12D AE E3 (Tier 3) Fault Code: PID84 FMI 9 Road Speed

Volvo All Engines (2013 Emissions) Fault Code: P004591 PID: EMS Turbocharger/Supercharger Boost Control “A” Circuit / Open

Detroit DD13 GHG14 (2014-16) Fault Code: SPN 5246 FMI 16 (ACM) Regulatory Fault Ignored – Final Action Pending

PACCAR PX-6 CM2150 (2007-09) Fault Code: 2374 PID: 131 SPN: 1209 FMI: 4 Exhaust Gas Pressure Sensor Circuit – Voltage Below Normal or Shorted to Low Source. Low signal voltage detected at the exhaust gas pressure circuit.

Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 3223 PID: SPN: 3490 FMI: 4 Aftertreatment Purge Air Actuator Circuit- Voltage Below Normal or Shorted to Low Source

Store

About

Features

Follow Us