Volvo All Engines (2010 Emissions) Fault Code: SPN 631 FMI 2 PID: PSID 124 Calibration memory

Category All Engines (2010 Emissions) Tags 124, 2, 2010, 631, All, Calibration, CodeSPN, Emissions, Engines, Fault, FMI, Memory, PIDPSID, Volvo

Conditions for diagnostic trouble code (DTC):
1) Software error
2) Checksum error, main software

Observable symptoms
1) Engine cannot be started

Probable cause
1) ACM EEPROM
2) Programmed with erroneous software
3) Programming sequence interrupted

CAT
CAT ET 2026 Diagnostic Software
$110.00 Add to cart
Detroit
DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026
$120.00 Add to cart
Detroit
DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025
$110.00 Add to cart
John Deere
John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible
$420.00 Add to cart

MAN MANTIS v666 EPC [09.2021] Spare Parts Catalog
MAN $80.00
premium volvo tech tool update 2.8.150 diagnostic software 1pc
Trucks software $150.00
Wabco Diagnostic Software 2021 (Tebs-E 6.01) + PINS
Trucks software $60.00

Volvo All Engines (2010 Emissions) Fault Code: SPN 631 FMI 2 PID: PSID 124 Calibration memory

CAT ET 2026 Diagnostic Software

DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026

DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025

John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible

MAN MANTIS v666 EPC [09.2021] Spare Parts Catalog

premium volvo tech tool update 2.8.150 diagnostic software 1pc

Wabco Diagnostic Software 2021 (Tebs-E 6.01) + PINS

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 3482 FMI 7 (MCM) Fuel Cutoff Valve Failed Self Test

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 520296 FMI 13 (MCM) Exhaust Gas Recirculation Valve Actuator Error

Cummins ISB CM850 (2003-06) Fault Code: 2274 PID: 411 SPN: 411 FMI: 4 EGR valve differential pressure sensor circuit – shorted low. Low signal voltage detected on the EGR valve differential pressure sensor circuit.

Volvo All Engines (2013 Emissions) Fault Code: P012800 PID: EMS Coolant Thermostat (Cooolant Below Thermostat Regulating Temperature)

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 190 FMI 16 (MCM) Engine Over Speed While Stationary

Detroit DD15 EPA07 (2007-09) Fault Code: SPN 599 FMI 4 (CPC) Both Cruise Control Switches, Set and Res, are Shorted to Ground

Cummins ISC CM2150 (2007-09) Fault Code: 2195 PID: SID 51 SPN: 703 FMI: 14 Auxiliary Equipment Sensor Input 3 Engine Protection Critical – Special Instructions. The emergency door of the vehicle has been detected open.

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 4294 PID: SPN: 5097 FMI: 4 Engine Brake Active Lamp- Voltage Below Normal or Shorted to Low Source

Detroit DD16 EPA10 (2010-13) Fault Code: SPN 3660 FMI 4 (MCM) Injector Cylinder #2 Amplifier Control Valve Abnormal Operation (MIN)

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 703 FMI 5 (CPC) Water In Fuel (WIF) Sensor Indicates an Open Circuit in the Wiring to Pin 09 of the CPC #3 Connector

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 2646 FMI 3 (CPC) Short to Power

Cummins ISB4.5 CM2150 Fault Code: 2369 PID: SPN: 1074 FMI: 4 Engine (Exhaust) Brake Driver Circuit – Voltage Below Normal or Shorted to Low Source.

PACCAR MX (2004 Emissions) Fault Code: U1855 Catalytic Convertor Temperature Sensors ECU Software Verification – Incorrect

Detroit DD16 EPA07 (2007-09) Fault Code: SPN 973 FMI 9 (CPC) Electronic Brake Controller (EBC1) (Engine Brake Switches) is Missing

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 155 PID: 105 SPN: 105 FMI: 0 Intake Manifold 1 Temperature – Data Valid but Above Normal Operational Range – Most Severe Level. Intake manifold air temperature signal indicates intake manifold air temperature above engine protection critical limit.

Volvo All Engines (2017 Emissions) Fault Code: P052064 PID: EMS Engine Oil Pressure Sensor/Switch “A”

Cummins ISL CM850 (2003-06) Fault Code: 332 PID: SID 4 SPN: 654 FMI: 5 Injector Solenoid Driver Cylinder 4 Circuit – Current Below Normal or Open Circuit. High resistance or no current detected at number 4 injector driver or RETURN pin.

Store

About

Features

Follow Us

Volvo All Engines (2010 Emissions) Fault Code: SPN 631 FMI 2 PID: PSID 124 Calibration memory

CAT ET 2026 Diagnostic Software

DETROIT DIESEL DIAGNOSTIC LINK 8.23 SP2 2026

DETROIT DIESEL DIAGNOSTIC LINK DDDL 8.20 SP1 2025

John Deere Service Advisor 5.4.44 2025 (AG & CF) | Nexiq USB Link 3 Compatible

MAN MANTIS v666 EPC [09.2021] Spare Parts Catalog

premium volvo tech tool update 2.8.150 diagnostic software 1pc

Wabco Diagnostic Software 2021 (Tebs-E 6.01) + PINS

Related products

PACCAR PX-8 CM2150 (2007-09) Fault Code: 1896 PID: SID 146 SPN: 2791 FMI: 13 EGR Valve Controller – Out of Calibration. The EGR valve has failed the automatic calibration procedure at initial key-on.

Cummins ISB4.5 CM2150 Fault Code: 346 PID: 253 SPN: 630 FMI: 12 Engine Control Module Calibration Memory Software – Bad Intelligent Device or Component.

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 286 PID: SID 231 SPN: 639 FMI: 13 SAE J1939 Multiplexing Configuration Error – Out of Calibration. The ECM expected information from a multiplexed device but only received a portion of the necessary information.

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 3717 PID: SPN: 3226 FMI: 13 Aftertreatment Outlet Nox Sensor- Out of Calibration

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 4431 PID: SPN: 3360 FMI: 13 Aftertreatment Diesel Exhaust Fluid Controller- Out of Calibration

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 1691 PID: SPN: 3250 FMI: 13 Catalyst Efficiency – Out of Calibration. The temperature increase across the aftertreatment diesel oxidation catalyst is lower than expected.

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 346 (MD) PID: SID 253 SPN: 630 FMI: 12 Engine Control Module Calibration Memory Software- Bad Intelligent Device or Component

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 2449 PID: SID 027 SPN: 641 FMI: 13 VGT Actuator Controller – Out of Calibration. The VGT has failed the automatic calibration procedure at initial key-ON.

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 432 PID: SID 230 SPN: 558 FMI: 13 Accelerator Pedal or Lever Idle Validation Circuit – Out of Calibration. Voltage at idle validation on-idle and off-idle circuit does not match accelerator pedal position.

PACCAR PX-6 CM2150 (2007-09) Fault Code: 2449 PID: SID 027 SPN: 641 FMI: 13 VGT Actuator Controller – Out of Calibration. The VGT has failed the automatic calibration procedure at initial key-ON.

PACCAR PX-8 CM2150 (2007-09) Fault Code: 2635 PID: SID 027 SPN: 641 FMI: 11 VGT Actuator Driver Circuit – Condition Exists. A calibration mismatch between the VGT actuator and the ECM has been detected.

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 3697 PID: SID 254 SPN: 630 FMI: 12 Engine Control Module Calibration Memory- Bad Intelligent Device or Component

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 3482 FMI 7 (MCM) Fuel Cutoff Valve Failed Self Test

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 520296 FMI 13 (MCM) Exhaust Gas Recirculation Valve Actuator Error

Cummins ISB CM850 (2003-06) Fault Code: 2274 PID: 411 SPN: 411 FMI: 4 EGR valve differential pressure sensor circuit – shorted low. Low signal voltage detected on the EGR valve differential pressure sensor circuit.

Volvo All Engines (2013 Emissions) Fault Code: P012800 PID: EMS Coolant Thermostat (Cooolant Below Thermostat Regulating Temperature)

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 190 FMI 16 (MCM) Engine Over Speed While Stationary

Detroit DD15 EPA07 (2007-09) Fault Code: SPN 599 FMI 4 (CPC) Both Cruise Control Switches, Set and Res, are Shorted to Ground

Cummins ISC CM2150 (2007-09) Fault Code: 2195 PID: SID 51 SPN: 703 FMI: 14 Auxiliary Equipment Sensor Input 3 Engine Protection Critical – Special Instructions. The emergency door of the vehicle has been detected open.

Cummins ISX11.9 CM2250 (2010-12) Fault Code: 4294 PID: SPN: 5097 FMI: 4 Engine Brake Active Lamp- Voltage Below Normal or Shorted to Low Source

Detroit DD16 EPA10 (2010-13) Fault Code: SPN 3660 FMI 4 (MCM) Injector Cylinder #2 Amplifier Control Valve Abnormal Operation (MIN)

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 703 FMI 5 (CPC) Water In Fuel (WIF) Sensor Indicates an Open Circuit in the Wiring to Pin 09 of the CPC #3 Connector

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 2646 FMI 3 (CPC) Short to Power

Cummins ISB4.5 CM2150 Fault Code: 2369 PID: SPN: 1074 FMI: 4 Engine (Exhaust) Brake Driver Circuit – Voltage Below Normal or Shorted to Low Source.

PACCAR MX (2004 Emissions) Fault Code: U1855 Catalytic Convertor Temperature Sensors ECU Software Verification – Incorrect

Detroit DD16 EPA07 (2007-09) Fault Code: SPN 973 FMI 9 (CPC) Electronic Brake Controller (EBC1) (Engine Brake Switches) is Missing

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 155 PID: 105 SPN: 105 FMI: 0 Intake Manifold 1 Temperature – Data Valid but Above Normal Operational Range – Most Severe Level. Intake manifold air temperature signal indicates intake manifold air temperature above engine protection critical limit.

Volvo All Engines (2017 Emissions) Fault Code: P052064 PID: EMS Engine Oil Pressure Sensor/Switch “A”

Cummins ISL CM850 (2003-06) Fault Code: 332 PID: SID 4 SPN: 654 FMI: 5 Injector Solenoid Driver Cylinder 4 Circuit – Current Below Normal or Open Circuit. High resistance or no current detected at number 4 injector driver or RETURN pin.

Store

About

Features

Follow Us