Volvo All Engines (2010 Emissions) Fault Code: SPN 412 FMI 4 PID: Engine Exhaust Gas Recirculation Temperature

Category All Engines (2010 Emissions) Tags 2010, 4, 412, All, CodeSPN, Emissions, Engine, Engines, Exhaust, Fault, FMI, Gas, PID, Recirculation, Temperature, Volvo

This function is used to check if the Exhaust Gas Recirculation (EGR) temperature sensor is working and check the status on the EGR cooler. If the sensor should show a value above limit due to extreme driving or malfunction in the cooler, the Engine Control Module (ECM) will derate the engine to avoid damage.

Conditions for diagnostic trouble code (DTC):
1) The voltage at pin A14.EB:48 is less than 0.024?V

Observable symptoms
1) Engine de-rated

Probable cause
1) Connector
2) Temperature sensor, EGR
3) Open circuit, Ground wire
4) Short circuit to higher voltage, Signal wire
5) Wiring harness
6) Engine control module (ECM)

CLAAS
CLAAS MetaDiag 2007 Update 2016
Rated 0 out of 5
$200.00 Add to cart
ISUZU
Isuzu US-IDSS 2024 Diagnostic
Rated 0 out of 5
$220.00 Add to cart
ISUZU
Isuzu E-IDSS 2023 Diagnostic Software
Rated 0 out of 5
$150.00 Add to cart
ISUZU
ISUZU G-IDSS Domestic Japan 2024 Diagnostic Software
Rated 0 out of 5
$220.00 Add to cart

MAN MANTIS v666 EPC [09.2021] Spare Parts Catalog
MAN $80.00
Rated 0 out of 5
Hino Diagnostic eXplorer 2 – Hino DX2 1.1.19.1 with keygen unlocked ( Hino trucks )
Hino $50.00
Rated 0 out of 5
CAT Engine Reprogramming Tool for flash programming C1.8, C2.4, C3.8 & C3.3B + Guide
CAT $50.00
Rated 0 out of 5
VOLVO PREMIUM TECH TOOL PTT 2.7.116 + APCI 2021 + devtool ( ONLINE )
Trucks software $80.00
Rated 0 out of 5
Hino DX3 2025 Diagnostic Software
Hino $95.00
Rated 0 out of 5
JPRO 2023 v3 diagnostic software latest version
JPRO $100.00
Rated 0 out of 5
PERKINS EST 2024 Diagnostic Software
Perkins $100.00
Rated 0 out of 5
Diamond Logic Builder DLB 2018
Navistar $40.00
Rated 0 out of 5
NEXIQ eTechnician 2.1.7657.26963 + Patch 2020
Allison $60.00
Rated 0 out of 5
Isuzu E-IDSS 2023 Diagnostic Software
ISUZU $150.00
Rated 0 out of 5
DETROIT DDDL 8.14 SP3 – Detroit Diesel Diagnostic Link 8.14 SP3 2021 ( 1PC )
Detroit $73.00
Rated 0 out of 5
Detroit Diesel Switcher Tool + Video Manual
Detroit $12.00
Rated 0 out of 5

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 4257 FMI 3 (MCM) Injector Amplifier Control Valve Cylinder 1, 2, 3 Shorted to Battery
DD16 GHG14 (2014-16)
Rated 0 out of 5
Cummins ISB6.7 CM2150 (2007-09) Fault Code: 529 PID: SID 051 SPN: 703 FMI: 3 Auxiliary Input/Output 3 Circuit – Voltage Above Normal or Shorted to High Source. High signal voltage has been detected at the auxiliary input/output 3 circuit.
Cumminz
Rated 0 out of 5
Cummins X15 CM2350 X116B Performance Series (2018 & Newer) Fault Code: 2637 (X) PID: SID 380 SPN: 5018 FMI: 11 Aftertreatment Diesel Oxidation Catalyst face Plugged- Root Cause Not Known
Cumminz
Rated 0 out of 5
PACCAR MX (2004 Emissions) Fault Code: P1480 EGR Valve Module Position – Unable to Reach Target
MX (2004 Emissions)
Rated 0 out of 5
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 3511 FMI 4 (CPC) Remote Accelerator Pedal Supply Voltage Circuit Failed Low
DD16 GHG14 (2014-16)
Rated 0 out of 5
Detroit DD13 GHG14 (2014-16) Fault Code: SPN 3563 FMI 4 (MCM) Intake Manifold Pressure Circuit Failed Low
DD13 GHG14 (2014-16)
Rated 0 out of 5
Detroit DD13 GHG14 (2014-16) Fault Code: SPN 2791 FMI 7 (MCM) Smart Remote Actuator 3 (EGR), Failsafe Mode, Motor Off
DD13 GHG14 (2014-16)
Rated 0 out of 5
PACCAR MX (2004 Emissions) Fault Code: P2605 Coolant Pump – Voltage Too Low or Short Circuit to Ground on ECU (D420) Pin (C1)
MX (2004 Emissions)
Rated 0 out of 5
Detroit DD15 GHG14 (2014-16) Fault Code: SPN 164 FMI 4 (MCM) Fuel Rail Pressure Sensor Circuit Failed Low (Short to Ground)
DD15 GHG14 (2014-16)
Rated 0 out of 5
Allison WTEC II Fault Code: 24 PID: SPN: 12 FMI: Sump fluid temperature, cold
Allison
Rated 0 out of 5
Detroit DD16 GHG14 (2014-16) Fault Code: SPN 600 FMI 13 (CPC) J1939 Cruise Coast Switch Signal from Source #1, #2 Or #3 is Missing
DD16 GHG14 (2014-16)
Rated 0 out of 5
PACCAR PX-8 CM2150 (2007-09) Fault Code: 285 PID: SID 231 SPN: 639 FMI: 9 SAE J1939 Multiplexing PGN Timeout Error – Abnormal Update Rate. The ECM expected information from a multiplexed device but did not receive it soon enough or did not receive it at all.
DTC TRUCKS
Rated 0 out of 5
PACCAR PX-6 CM2150 (2007-09) Fault Code: 197 PID: 111 SPN: 111 FMI: 1 Coolant Level – Data Valid but Below Normal Operating Range – Moderately Severe Level. Low engine coolant level detected.
DTC TRUCKS
Rated 0 out of 5
Volvo Engine D11L (Tier 4) Fault Code: PID 111 FMI 3 Coolant Level
D11L (Tier 4)
Rated 0 out of 5
Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 4152 PID: SPN: 5743 FMI: 9 Aftertreatment Selective Catalytic Reduction Temperature Sensor Module- Abnormal Update Rate
Cumminz
Rated 0 out of 5
Cummins X15 CM2350 X116B Performance Series (2018 & Newer) Fault Code: 1685 PID: SPN: 3364 FMI: 4 Aftertreatment Diesel Exhaust Fluid Quality Sensor Circuit- Voltage Below Normal or Shorted to Low Source
Cumminz
Rated 0 out of 5
Volvo All Engines (2013 Emissions) Fault Code: P111386 PID: EMS Exhausy Gas Temperature Sensor Bank 1 Sensor 3 Electrical
All Engines (2013 Emissions)
Rated 0 out of 5
PACCAR PX-6 CM2150 (2007-09) Fault Code: 2451 PID: SPN: 2789 FMI: 0 Turbocharger Turbine Inlet Temperature (Calculated) – Data Valid but Above Normal Operational Range – Moderately Severe Level. Turbocharger turbine inlet temperature has exceeded the engine protection limit.
DTC TRUCKS
Rated 0 out of 5

Volvo All Engines (2010 Emissions) Fault Code: SPN 412 FMI 4 PID: Engine Exhaust Gas Recirculation Temperature

CLAAS MetaDiag 2007 Update 2016

Isuzu US-IDSS 2024 Diagnostic

Isuzu E-IDSS 2023 Diagnostic Software

ISUZU G-IDSS Domestic Japan 2024 Diagnostic Software

MAN MANTIS v666 EPC [09.2021] Spare Parts Catalog

Hino Diagnostic eXplorer 2 – Hino DX2 1.1.19.1 with keygen unlocked ( Hino trucks )

CAT Engine Reprogramming Tool for flash programming C1.8, C2.4, C3.8 & C3.3B + Guide

VOLVO PREMIUM TECH TOOL PTT 2.7.116 + APCI 2021 + devtool ( ONLINE )

Hino DX3 2025 Diagnostic Software

JPRO 2023 v3 diagnostic software latest version

PERKINS EST 2024 Diagnostic Software

Diamond Logic Builder DLB 2018

NEXIQ eTechnician 2.1.7657.26963 + Patch 2020

Isuzu E-IDSS 2023 Diagnostic Software

DETROIT DDDL 8.14 SP3 – Detroit Diesel Diagnostic Link 8.14 SP3 2021 ( 1PC )

Detroit Diesel Switcher Tool + Video Manual

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 4257 FMI 3 (MCM) Injector Amplifier Control Valve Cylinder 1, 2, 3 Shorted to Battery

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 529 PID: SID 051 SPN: 703 FMI: 3 Auxiliary Input/Output 3 Circuit – Voltage Above Normal or Shorted to High Source. High signal voltage has been detected at the auxiliary input/output 3 circuit.

Cummins X15 CM2350 X116B Performance Series (2018 & Newer) Fault Code: 2637 (X) PID: SID 380 SPN: 5018 FMI: 11 Aftertreatment Diesel Oxidation Catalyst face Plugged- Root Cause Not Known

PACCAR MX (2004 Emissions) Fault Code: P1480 EGR Valve Module Position – Unable to Reach Target

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 3511 FMI 4 (CPC) Remote Accelerator Pedal Supply Voltage Circuit Failed Low

Detroit DD13 GHG14 (2014-16) Fault Code: SPN 3563 FMI 4 (MCM) Intake Manifold Pressure Circuit Failed Low

Detroit DD13 GHG14 (2014-16) Fault Code: SPN 2791 FMI 7 (MCM) Smart Remote Actuator 3 (EGR), Failsafe Mode, Motor Off

PACCAR MX (2004 Emissions) Fault Code: P2605 Coolant Pump – Voltage Too Low or Short Circuit to Ground on ECU (D420) Pin (C1)

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 164 FMI 4 (MCM) Fuel Rail Pressure Sensor Circuit Failed Low (Short to Ground)

Allison WTEC II Fault Code: 24 PID: SPN: 12 FMI: Sump fluid temperature, cold

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 600 FMI 13 (CPC) J1939 Cruise Coast Switch Signal from Source #1, #2 Or #3 is Missing

PACCAR PX-8 CM2150 (2007-09) Fault Code: 285 PID: SID 231 SPN: 639 FMI: 9 SAE J1939 Multiplexing PGN Timeout Error – Abnormal Update Rate. The ECM expected information from a multiplexed device but did not receive it soon enough or did not receive it at all.

PACCAR PX-6 CM2150 (2007-09) Fault Code: 197 PID: 111 SPN: 111 FMI: 1 Coolant Level – Data Valid but Below Normal Operating Range – Moderately Severe Level. Low engine coolant level detected.

Volvo Engine D11L (Tier 4) Fault Code: PID 111 FMI 3 Coolant Level

Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 4152 PID: SPN: 5743 FMI: 9 Aftertreatment Selective Catalytic Reduction Temperature Sensor Module- Abnormal Update Rate

Cummins X15 CM2350 X116B Performance Series (2018 & Newer) Fault Code: 1685 PID: SPN: 3364 FMI: 4 Aftertreatment Diesel Exhaust Fluid Quality Sensor Circuit- Voltage Below Normal or Shorted to Low Source

Volvo All Engines (2013 Emissions) Fault Code: P111386 PID: EMS Exhausy Gas Temperature Sensor Bank 1 Sensor 3 Electrical

PACCAR PX-6 CM2150 (2007-09) Fault Code: 2451 PID: SPN: 2789 FMI: 0 Turbocharger Turbine Inlet Temperature (Calculated) – Data Valid but Above Normal Operational Range – Moderately Severe Level. Turbocharger turbine inlet temperature has exceeded the engine protection limit.

Store

About

Features

Follow Us

Volvo All Engines (2010 Emissions) Fault Code: SPN 412 FMI 4 PID: Engine Exhaust Gas Recirculation Temperature

CLAAS MetaDiag 2007 Update 2016

Isuzu US-IDSS 2024 Diagnostic

Isuzu E-IDSS 2023 Diagnostic Software

ISUZU G-IDSS Domestic Japan 2024 Diagnostic Software

MAN MANTIS v666 EPC [09.2021] Spare Parts Catalog

Hino Diagnostic eXplorer 2 – Hino DX2 1.1.19.1 with keygen unlocked ( Hino trucks )

CAT Engine Reprogramming Tool for flash programming C1.8, C2.4, C3.8 & C3.3B + Guide

VOLVO PREMIUM TECH TOOL PTT 2.7.116 + APCI 2021 + devtool ( ONLINE )

Hino DX3 2025 Diagnostic Software

JPRO 2023 v3 diagnostic software latest version

PERKINS EST 2024 Diagnostic Software

Diamond Logic Builder DLB 2018

NEXIQ eTechnician 2.1.7657.26963 + Patch 2020

Isuzu E-IDSS 2023 Diagnostic Software

DETROIT DDDL 8.14 SP3 – Detroit Diesel Diagnostic Link 8.14 SP3 2021 ( 1PC )

Detroit Diesel Switcher Tool + Video Manual

Related products

PACCAR Engine Analyzer v1.3.0.6

Cummins ISB4.5 CM2150 Fault Code: 4284 PID: SPN: 5793 FMI: 9 Desired Engine Fueling State – Abnormal Update Rate.

Cummins ISB4.5 CM2150 Fault Code: 2555 PID: SPN: 729 FMI: 3 Engine Intake Air Heater 1 Circuit – Voltage Above Normal or Shorted to High Source.

Cummins ISB4.5 CM2150 Fault Code: 111 PID: 629 FMI:12 Engine Control Module Critical Internal Failure – Bad Intelligent Device or Component

Cummins ISB4.5 CM2150 Fault Code: 2321 PID: 190 SPN: 190 FMI: 2 Engine Crankshaft Speed/Position – Data Erratic, Intermittent, or Incorrect.

Cummins ISB4.5 CM2150 Fault Code: 2556 PID: SPN: 729 FMI: 4 Engine Intake Air Heater 1 Circuit – Voltage Below Normal or Shorted to Low Source.

Cummins ISB4.5 CM2150 Fault Code: 3382 PID: SPN: 3058 FMI: 18 Engine Exhaust Gas Recirculation System – Data Valid But Below Normal Operating Range – Moderately Severe Level.

Cummins ISB4.5 CM2150 Fault Code: 3139 PID: SPN: 3667 FMI: 3 Engine Air Shutoff Circuit – Voltage Above Normal or Shorted to High Source.

Cummins ISB4.5 CM2150 Fault Code: 3555 PID: SPN: 1081 FMI: 9 Engine Wait to Start Lamp – Abnormal Update Rate.

Cummins ISB4.5 CM2150 Fault Code: 3141 PID: 102 SPN: 3667 FMI: 4 Engine Air Shutoff Sensor Circuit – Voltage Below Normal or Shorted to Low Source.

Cummins ISB4.5 CM2150 Fault Code: 3735 PID: SPN: 2884 FMI: 9 Engine Auxiliary Governor Switch – Abnormal Update Rate.

Cummins ISB4.5 CM2150 Fault Code: 2371 PID: SPN: 1074 FMI: 3 Engine (Exhaust) Brake Driver Circuit – Voltage Above Normal or Shorted to High Source.

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 4257 FMI 3 (MCM) Injector Amplifier Control Valve Cylinder 1, 2, 3 Shorted to Battery

Cummins ISB6.7 CM2150 (2007-09) Fault Code: 529 PID: SID 051 SPN: 703 FMI: 3 Auxiliary Input/Output 3 Circuit – Voltage Above Normal or Shorted to High Source. High signal voltage has been detected at the auxiliary input/output 3 circuit.

Cummins X15 CM2350 X116B Performance Series (2018 & Newer) Fault Code: 2637 (X) PID: SID 380 SPN: 5018 FMI: 11 Aftertreatment Diesel Oxidation Catalyst face Plugged- Root Cause Not Known

PACCAR MX (2004 Emissions) Fault Code: P1480 EGR Valve Module Position – Unable to Reach Target

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 3511 FMI 4 (CPC) Remote Accelerator Pedal Supply Voltage Circuit Failed Low

Detroit DD13 GHG14 (2014-16) Fault Code: SPN 3563 FMI 4 (MCM) Intake Manifold Pressure Circuit Failed Low

Detroit DD13 GHG14 (2014-16) Fault Code: SPN 2791 FMI 7 (MCM) Smart Remote Actuator 3 (EGR), Failsafe Mode, Motor Off

PACCAR MX (2004 Emissions) Fault Code: P2605 Coolant Pump – Voltage Too Low or Short Circuit to Ground on ECU (D420) Pin (C1)

Detroit DD15 GHG14 (2014-16) Fault Code: SPN 164 FMI 4 (MCM) Fuel Rail Pressure Sensor Circuit Failed Low (Short to Ground)

Allison WTEC II Fault Code: 24 PID: SPN: 12 FMI: Sump fluid temperature, cold

Detroit DD16 GHG14 (2014-16) Fault Code: SPN 600 FMI 13 (CPC) J1939 Cruise Coast Switch Signal from Source #1, #2 Or #3 is Missing

PACCAR PX-8 CM2150 (2007-09) Fault Code: 285 PID: SID 231 SPN: 639 FMI: 9 SAE J1939 Multiplexing PGN Timeout Error – Abnormal Update Rate. The ECM expected information from a multiplexed device but did not receive it soon enough or did not receive it at all.

PACCAR PX-6 CM2150 (2007-09) Fault Code: 197 PID: 111 SPN: 111 FMI: 1 Coolant Level – Data Valid but Below Normal Operating Range – Moderately Severe Level. Low engine coolant level detected.

Volvo Engine D11L (Tier 4) Fault Code: PID 111 FMI 3 Coolant Level

Cummins X12 CM2350 X119B (2018 & Newer) Fault Code: 4152 PID: SPN: 5743 FMI: 9 Aftertreatment Selective Catalytic Reduction Temperature Sensor Module- Abnormal Update Rate

Cummins X15 CM2350 X116B Performance Series (2018 & Newer) Fault Code: 1685 PID: SPN: 3364 FMI: 4 Aftertreatment Diesel Exhaust Fluid Quality Sensor Circuit- Voltage Below Normal or Shorted to Low Source

Volvo All Engines (2013 Emissions) Fault Code: P111386 PID: EMS Exhausy Gas Temperature Sensor Bank 1 Sensor 3 Electrical

PACCAR PX-6 CM2150 (2007-09) Fault Code: 2451 PID: SPN: 2789 FMI: 0 Turbocharger Turbine Inlet Temperature (Calculated) – Data Valid but Above Normal Operational Range – Moderately Severe Level. Turbocharger turbine inlet temperature has exceeded the engine protection limit.

Store

About

Features

Follow Us